Home
Wacker Neuson
Lighting Equipment
LTN 6L
Wacker Neuson LTN 6L User Manual
4
of 1
of 1 rating
118 pages
Give review
Manual
Specs
To Previous Page
To Previous Page
Loading...
Wacker Neuson SE · Preußenstraße 41 ·
D-80809
München · Tel.: +49-(0)89-3 54 02-0 · Fa
x: +49 - (0)89-3 54 02-390
Wacker Neuson Corporation · N92W15000 Anthon
y Ave. · Menomonee Falls, WI 53051 · Tel. : (262) 255-050
0 · Fax: (262) 25
5-055
0 ·Tel. : (800
) 770-0957
Wacker Neuson Limited - Room 1701–03 & 1717–20, 17/
F. Tower 1, Grand Century Place, 193 Prince Edward Road West
, Mongkok, Kowlo
o
n, Hongkong.
Tel: (852) 3605 5360, Fax: (852) 2758 0032
117
Table of Contents
Default Chapter
3
Default Chapter
3
Table of Contents
3
Foreword
7
1 Safety Information
9
Signal Words Used in this Manual
9
Machine Description and Intended Use
10
Safety Guidelines for Operating the Machine
11
Operator Safety While Using Internal Combustion Engines
13
Lamp Safety
14
Service Safety
14
2 Labels
16
Label Locations
16
Label Meanings
18
3 Lifting the Machine
30
Procedure
30
4 Operation
31
Locating Trailer
31
Leveling Trailer
32
Adjusting Lights
33
Preparing Trailer for Towing or Lifting
34
Raising Tower (Manual Winch System)
35
Lowering Tower (Manual Winch System)
38
Raising Tower (Power Winch System)
40
Lowering Tower (Power Winch System)
42
Emergency Crank Handle (Power Winch System)
43
Control Panels (Manual Winch System)
44
Control Panels (120/240, Manual Winch System)
45
Control Panels (Power Winch System)
46
Starting
47
Manual Shutdown
47
Automatic Shutdown
47
Operating Lights
48
Stopping
48
Derating
48
Receptacle
49
5 Factory Installed Options
50
Block Heater
50
Battery Blanket
51
Oil Pan Heater
51
6 Maintenance
52
Periodic Maintenance Schedule
52
Installing / Removing Light Fixtures
53
Replacing / Removing Lamps
54
Daily Inspection
55
Air Cleaner
56
Engine Oil
56
Troubleshooting
57
7 Technical Data
58
Engine
58
Generator
59
Machine
59
8 Schematics
60
Electrical Schematic
60
Electrical Schematic (120/240)
62
Trailer Wiring
64
Engine Wiring - Lombardini
65
Control Panel Wiring
66
Power Winch Schematic
67
9 Appendix I-Assembly Instructions
68
Introduction
68
10 Appendix II-Assembly Safety
70
Signal Words Found in this Manual
70
Lifting Safety
71
Pre-Assembly Checklist
71
11 Appendix III-Standard Pallet Assembly
72
Installing the Outriggers and Outrigger Jacks
73
Installing the Rear Jack
74
Installing the Tongue Assembly
75
Installing the Upper Light Fixtures
77
Conclusion
78
12 Appendix IV-Ce Pallet Assembly
79
Install the Outrigger Jacks
79
Install the Rear Jack
79
Tools and the Following Tools and Materials Are Needed
79
Installing the Side Jacks
80
Installing the Rear Jack
81
Conclusion
82
13 Appendix V-Standard Racked Assembly
83
Installing the Axle
84
Materials Basic Hand Tools (Wrenches, Screwdrivers, Etc.)
84
Torque Wrench
84
Installing the Fenders
85
Installing the Wheels
85
Installing the Outriggers and Outrigger Jacks
86
Installing the Rear Jack
87
Installing the Tongue Assembly
88
Installing the Tower Lock Bracket
90
Installing the Tower Cradle
91
Installing the Tower
92
Installing the Tower Pivot Cable
93
Installing the Lights
94
Connecting the Wiring at the Junction Box
95
Hardware Bag 6
95
Routing the Coil Cord
97
Wiring the Ballasts and Terminal Strips
98
Conclusion
100
14 Appendix VI-Ce Racked Assembly
101
Attaching the Outriggers and Outrigger Jacks
103
Attaching the Rear Jack
104
Attaching the Tower Lock Bracket
105
Attaching the Tower Cradle
105
Installing the Tower
106
Installing the Tower Pivot Cable
108
Attaching the Light Mount Bracket and Light Bar
109
Attaching the Lights
110
Wiring the Junction Box
111
Routing the Coil Cord
113
Wiring the Ballasts and Terminal Strips
114
4
Based on 1 rating
Ask a question
Give review
Questions and Answers:
Need help?
Do you have a question about the Wacker Neuson LTN 6L and is the answer not in the manual?
Ask a question
Wacker Neuson LTN 6L Specifications
General
Brand
Wacker Neuson
Model
LTN 6L
Category
Lighting Equipment
Language
English
Related product manuals
Wacker Neuson LTN6L-V
78 pages
To Previous PageTo Previous Page
Loading...
Need help?
General
