Buell X1 2002 - Page 362

6-2 2002 Buell X1: Drive/Transmission
HOME
TORQUE VALUES
ITEM TORQUE NOTES
Access Door Mounting Bolts 13-17 ft-lbs 18-23 Nm
LOCTITE THREADLOCKER 243 (blue),
page 6-34
Clutch Mainshaft Nut 70-80 ft-lbs 95-109 Nm
LOCTITE THREADLOCKER 262 (red), left
hand threads, page 6-16
Countershaft Retainer TORX Screw 13-17 ft-lbs 18-23 Nm
LOCTITE THREADLOCKER 243 (blue),
page 6-29
Engine Sprocket Nut 190-210 ft-lbs 258-285 Nm
LOCTITE THREADLOCKER 262 (red),
page 6-16
Footrest Mount Bolts 10-15 ft-lbs 14-20 Nm page 6-7
Isolator TORX Bolts, Rear 63-70 ft-lbs 85-95 Nm
LOCTITE THREADLOCKER 262 (red),
ANTI-SEIZE under bolt heads, special pro-
cedure, page 6-7
Primary Chain Adjuster Locknut (exterior) 20-25 ft-lbs 27-34 Nm on exterior of chaincase, page 6-4
Primary Chain Adjuster Locknut (interior) 15-18 ft-lbs 20-24 Nm on interior of chaincase, page 6-4
Primary Chain Inspection Cover Screws 40-60 in-lbs 5-7 Nm page 6-3
Primary Cover Mounting Screws 100-120 in-lbs 11-14 Nm 3 lengths, page 6-5
Large primary cover screws 16-28 ft-lbs 22-38 Nm page 6-5
Shifter Lever Mounting Bolt 27-29 ft-lbs 37-39 Nm
LOCTITE THREADLOCKER 243 (blue),
page 6-5
Shifter Shaft Assembly Locknuts (top and
bottom)
90-110 in-lbs 10-12 Nm tighten bottom nut first, page 6-34
Shifter Upper Clamp Pinch Screw 59-66 in-lbs 7-8 Nm
LOCTITE THREADLOCKER 243 (blue),
page 6-5
Sideplate Screws 19 ft-lbs 26 Nm page 6-7
Transmission Detent Plate Nut 13-17 ft-lbs 18-23 Nm page 6-22
Transmission Drain Plug 14-30 ft-lbs 19-41 Nm remove debris from end, page 6-5
Transmission Sprocket Nut
58 ft-lbs then
an additional
30-40 degrees
68 Nm then an
additional 30-40
degrees
LOCTITE THREADLOCKER 262 (red), left
hand threads, special torque & turn
method, page 6-35
Transmission Sprocket Screws 90-110 in-lbs 10-12 Nm replace after 3 removals, page 6-36