22.10.19 Inhalt/Contens Seite/Page 7
Inhalt / Contens
4.2.4 Protection conductor: ...................................................................................................... .... 59
4.2.5 Operating control system on the Fischer Panda generator ............................................ .... 59
4.3 Instructions for capacitors - not present at all models .................................................................... .... 59
4.4 Checks before start, starting and stopping the generator............................................................... ....59
4.5 ........................................................................................................................................................ .... 60
5 Installation Instructions ......................................................................................................................... ..... 61
5.1 Personal requirements.................................................................................................................... .... 61
5.1.1 Hazard notes for the installation ..................................................................................... .... 61
5.2 Preparing the base - Placement .................................................................................................... ..... 63
5.2.1 Advice for optimal sound insulation ................................................................................ .... 63
5.3 Generator Connections................................................................................................................... .... 63
5.4 Installation of the cooling system - raw water ................................................................................. .... 64
5.4.1 General Information ........................................................................................................ .... 64
5.4.2 Installation of the through hull fitting in yyachts .............................................................. .... 64
5.4.3 Quality of the Raw Water Sucking In Line ...................................................................... .... 64
5.4.4 Generator installation above waterline ........................................................................... ..... 65
5.4.5 Generator Installation below waterline ........................................................................... ..... 66
5.4.6 Generator housing cooled by raw water ......................................................................... .... 67
5.4.7 Indirect cooling of the genset housing (by the heat exchanger) ..................................... ..... 68
5.5 Installation of the cooling system - fresh water............................................................................... .... 68
5.5.1 Position of the external cooling water expansion tank .................................................... .... 68
5.5.2 Ventilating at the first filling of the internal cooling water circuit ..................................... .... 69
5.5.3 Pressure test for controlling the cooling water circuit ..................................................... .... 70
5.5.4 Scheme for freshwater circuit at two circuit cooling system ........................................... ..... 71
5.6 Installation of the water cooled exhaust system ............................................................................ ..... 72
5.6.1 Installation of the standard exhaust system ................................................................... .... 72
5.7 .Installation of the waterlock ........................................................................................................... .... 73
5.7.1 Possible cause for water in the exhaust hose ................................................................ .... 73
5.7.1.1 Possible cause: exhaust hose.......................................................................... .... 73
5.7.1.2 Possible cause: cooling water hose ................................................................. .... 73
5.7.2 Installation area of the waterlock .................................................................................... .... 74
5.7.3 The volume of the waterlock ........................................................................................... .... 74
5.7.3.1 Ideal position of the waterlock.......................................................................... .... 75
5.7.3.2 Example of the installation of the waterlock off-center and possible effects: ... .... 76
5.8 Exhaust / water separator............................................................................................................... .... 77
5.8.1 Installation exhaust water separator ............................................................................... ..... 79
5.9 Installation of the fuel system ........................................................................................................ ..... 81
5.9.1 General references ......................................................................................................... .... 81
5.9.2 The electrical fuel pump ................................................................................................. .... 81
5.9.3 Connection of the fuel lines at the tank .......................................................................... .... 82
5.9.4 Position of the pre-filter with water separator ................................................................. .... 82
5.9.5 Ventilating air from the fuel system ................................................................................ .... 82
5.10 Generator DC system installation ................................................................................................... .... 83
5.10.1 Connection of the starter battery block ........................................................................... .... 83
5.10.2 Connection of the remote control panel - see separate control panel manual ............... .... 86
5.11 Generator AC system installation .................................................................................................. ..... 87
5.11.1 Insulation test ................................................................................................................. ..... 89
To Next Page
Loading...
