MAINTENANCE AND SERVICE
5
- 207 -
FAULT CAUSE AND REMEDY
ENGINE IS STALLING
Transfer pump does not intake, check the front fi lter.
Check main fuel fi lter.
The hole on the fuel tank cover may be clogged. Open it.
There is water in the fuel. Replace if necessary.
There is air in the fuel injection system. Check the fuel pipes and hoses.
Freezing or air ingress in the fuel settling bottle fi lter or fuel intake lines; check and clean
if required
.
ENGINE IS RUNNING
ROUGHLY
There may be air or clogging in the fuel pipes.
Bleed air.
Incorrect valve adjustment
Intake manifold or air fi lter may be clogged. Clean or replace. There is water in the fuel.
Replace if necessary.
There may be clogging or damage in the exhaust pipes or the muffl er. Have them
inspected.
Injector pump
intake may be insuffi cient. Contact an authorized dealer.
ENGINE IS DIFFICULT
TO START
Air fi lter may be contaminated. Clean or replace.
Starter is faulty. Have it repaired.
Battery discharged. Have it charged.
Exhaust system may be clogged. Have them inspected.
Front heater is faulty. Have them inspected.
Fuel level low. Top up.
There may be air in the fuel system. Bleed air .
Questions and Remedies
To Next Page
Loading...
