TROUBLESHOOTING
93
CLUTCH
Problem Possible Cause Remedy
Clutch slips • Poor clutch pedal adjustment
• Worn or burnt clutch lining
• Engine, transmission oil leak
Adjust free-play
Consult your dealer
Consult your dealer
Clutch will not disengage • Poor pedal adjustment
• Seized clutch lining
• Transmission shafts seized
Adjust free-play
Consult your dealer
Consult your dealer
BRAKES
Problem Possible Cause Remedy
Brakes do not work well or not
balanced with each other
when applied
• Too much free play of pedals
• Worn or seized linings
• Unequal pedal adjustment
Adjust free-play
Consult your dealer
Correct so both pedals are equal
HYDRAULIC SYSTEM
Problem Possible Cause Remedy
Insufficient oil pressure • Low engine speed
• Low transmission oil
• Intake piping is sucking air
• Clogged oil filer (s)
• Defective hydraulic oil pump
• Defective control valve
• Broken cylinder
Increases speed
Fill to specified level
Retighten clamps or replace cracked
pipes and defective O-rings
Clean or replace
Consult your dealer
Consult your dealer
Consult your dealer
Leaking piping
With control lever in RAISE
position, relief valve blows
3-point hitch does not lower
• Loose joints
• Cracked pipes
• Poorly adjusted rod on position
control lever
• Locked lowering rate control handle
• Defective control valve
• Broken cylinder
• Seized lift shaft bearing
Retighten
Replace pipes, O-rings
Correct rod adjustment
Turn counter clockwise to LOWERING
position
Consult your dealer
Consult your dealer
Consult your dealer
To Next Page
