LS tractor XP8084

To Next Page

To Previous Page

3 -71

1. Power shuttle filter

2. Sequence valve

3. Power shuttle control valve

4. TM control valve

5. Oil cooler

6. Oil cooler valve

7. Oil tank (Transmission case)

④ Power shuttle transmission hydraulic control line (PSS, optional)

Main Page

Table of Contents5
General Notices for Safety13
Note to the Owner - General Information13
Before Using the Tractor15
Manual Scope and Required Training Level17
Metric and Imperial Units Abbreviations19
Product Identification Number (PIN)21
Operator's Manual Storage23
Tractor Orientation24
Safety Precautions (Read this for Safety before Using)25
Notices before Using the Tractor25
Notices When Starting Engine29
Notices While Operating/Using the Tractor30
Notices When Connecting Implement32
Notices When Towing the Tractor33
Notices When Transporting the Tractor33
Notices When Servicing the Tractor after Work34
Notices When Handling Diesel Fuel35
Notices When Leaving the Tractor36
Notices Relating to Toxic Substances36
Tractor Stability37
Ecology and the Environment40
Symbols42
Safety Decals43
Instructional Decals49
Long-Term Storage54
Preparation for Storage54
Check & Maintenance During Storage55
Preparation for Reuse56
Instruction for Safe Operation57
The Name of each Part57
Boarding and Exiting the Tractor59
Boarding the Tractor59
Seat Adjustment60
Seat Belt62
Tilting Steering Wheel63
Ventilation (Cabin Only)63
Exiting the Tractor64
Safety Device66
Hood (Bonnet)66
Fender66
PTO Safety Cover and Protection Cap66
Roll-Over Protective Structure (ROPS) (Optional)67
Instruments and Controls71
Instrument Panel and Front Controls71
Instrument Panel72
Key Switch84
Throttle Pedal84
Clutch Pedal (MEC Models Only)85
Brake Pedals86
Shuttle Lever (MEC Models Only)87
Combination Light Switch88
Hazard Warning Light Switch91
Grille Work Light Switch (Optional)92
Beacon Lamp Switch (Cabin)93
4WD Switch94
Differential Lock Switch (Roll-Bar Type)95
PTO Switch (Roll-Bar Type, if Fitted)96
Desox Switch97
Right-Hand Controls and Cabin Pillar98
Throttle Lever101
Main Gear Shift Lever (MEC, PSS Models Only)102
Work Light Switch103
Window Wiper Switch (Cabin Type/Front, Rear)104
Electrical Power Outlet Socket (Cabin Type)105
Indoor Light (Cabin Type)105
Audio Player (Cabin Type)105
Differential Lock Switch(Cabin Type)106
PTO Switch107
PTO Mode Switch (if Fitted)108
PTO Switch (Cabin Type, if Fitted)109
Engine Speed Cruise Control(ESC) Switch110
Left-Hand Controls and Seat112
Range Gear Shift Lever (MEC, PSS Models Only)112
Creeper Gear Lever (if Fitted)114
PTO Gear Lever114
GSP Lever115
Parking Brake Lever115
Passenger Seat (Cabin Type, if Fitted)116
Beacon Lamp Switch (Roll-Bar Type, if Fitted)116
Power Shuttle System (PSS) (Optional)117
Power Shuttle Lever (PSS)117
Clutch Pedal (PSS)119
HI-LO Select Switch (PSS)120
Work/Drive Mode Select Switch (PSS)120
Error Diagnosis Code (PSS)121
Power Shift Transmission (PST) (Optional)122
Power Shuttle Lever (PST)122
Main Gear Shift Lever (PST)124
Range Gear Shift Lever (PST)125
Clutch Pedal (PST)126
Shift Mode Adjustment Dial (PST)127
Error Diagnosis Code (PST)128
Hydraulic System130
Safety Precautions130
Steering System131
Hydraulic Lift Control (MHL) (if Fitted)132
Remote Control Lever and Quick Coupler (Optional)135
Joystick Lever (Optional)136
Auto Lift Control (MHL)137
Hydraulic System Diagram138
Operation and Work143
How to Handle New Tractor143
Check Points143
Notices in Handling New Tractor (Engine Brake-In Procedure)143
Engine Start and Stop144
Engine Start144
Start in Cold Weather145
Engine Stop146
How to Drive and Stop147
Transmission Warm-Up in Cold Weather147
How to Drive148
Changing Speed150
Emergency Stop151
Stopping Tractor152
Parking153
Handling Turbocharger (if Fitted)153
Transport on Public Roads154
Safety Rules When Driving Tractor on the Roads154
Light Operation155
7-Pole Connector (Optional)157
Notices When Towing the Tractor158
Notices When Transporting the Tractor160
Field Operations161
Rear 3-Point Linkage161
Power Take-Off (PTO) Operation165
Hitch and Drawbar (Optional)169
Technically Maximum Permissible Mass170
Tires and Load Capacity171
Adjusting Wheel Tracks and Tire Replacement172
Using Front-End Loader (if Fitted)176
Adjusting Steering Angle179
Recommended Maximum Specification of Implements180
Ballasting Weights (Optional)181
Working in Hazardous Area184
Driving Speed185
Lubrication and Maintenance189
General Information189
Tightening Torque for Normal Assembly190
Standard Torque Data for Hydraulics192
General Specification - Diesel Fuel195
Biodiesel Fuel196
Refueling the Tractor198
Change Engine Coolant to Organic Acid Technology (OAT) Coolant199
Access for Maintenance200
Maintenance Chart201
Lubricants and Capacity203
First 50 Hour Check204
When the Warning Indicator Lights205
Fuel Filter Warning Indicator205
Engine Oil Pressure Indicator206
Battery Charging Indicator206
Checking before Starting (Daily Check)207
Engine Oil207
Fuel Tank & Def/Urea Tank208
Instrument Panel & Indicators211
Turn Signal Lights, Lights and Horn212
Engine Coolant212
Air Cleaner213
Cleaning Radiator and Radiator Screen214
Tire Air Pressure and Damage214
Tightening State of Bolts and Nuts of each Part215
Adjustment of Clutch Pedal Play216
Adjustment of Brake Pedal Play217
Every 50 Hour Check218
Lubricating Grease Nipple218
Cleaning Radiator and Radiator Screen218
Checking Transmission Oil219
Checking Front Axle Oil219
Battery Check220
Air Cleaner (Dry Type)220
Hydraulic Hoses and Leakage220
Cleaning Cabin Air Filter220
Every 300 Hour Check221
Replacing Hydraulic Oil Filter221
Replacing Power Shuttle Oil Filter (PSS Models Only)221
Replacing Power Shift Oil Filter (PST Models Only)222
Checking Brake Oil222
Tension of Fan Belt223
Toe-In223
In-Line Pressure Filter (Optional)223
Every 600 Hour Check224
Replacing Engine Oil and Filter224
Changing Front Axle Oil225
Changing Transmission Oil226
Replacing Fuel Filter Cartridge226
Checking Nozzle Injection Pressure227
Replacing Cabin Air Filters227
Every 1200 Hour or 1 Year Check228
Replacing Air Cleaner Element (Dry Type)228
Every 1800 Hour Check229
Replacing Blow-By Filter Element229
Every 3000 Hour or 2 Year Check230
Replacement of Engine Coolant230
Replacing Engine Fan Belt233
Replacing DEF Filter Element234
General Maintenance (When Required)237
Air-Bleeding from Fuel System237
Air-Bleeding from Brake Line239
Air-Bleeding from Clutch Line (MEC Models Only)239
Fuse & Main Fuse240
Battery Handling and Notices244
Alternator and Drive Belt - Check248
Tail/Brake Light and Turn Signal Light Bulb - Replace (Bulb Type)249
Headlight Bulb - Replace251
Touch-Up Paint Color252
Troubleshooting253
Engine Manufacturer's Warranty258
Air Conditioning System (Cabin Type)263
The Name of each Part of Cooling and Heating System263
How to Use Air Conditioner and Heater264
How to Operate Air Conditioner and Heater264
Air Direction Control264
Every 6 Month Check265
Checking Refrigerant Amount265
Cleaning Condenser and Radiator Screen265
Checking Leakage265
Belt Tension Adjustment266
Cleaning and Replacing Cabin Air Filters266
Every Year Check267
Compressor Check267
Control Switch Check267
Troubleshooting268
System Diagram270
Pneumatic System (Optional)271
Cleaning Air-Gun (Optional)271
Air-Gun System Configuration271
How to Use Air-Gun System272
Checking and Repairing Air-Gun System273
Pneumatic Trailer Brake System (Optional)274
Pneumatic Trailer Brake System Configuration274

LS tractor XP8084 - Page 141

Table of Contents

Related product manuals