18 - FORM NO. 56043124 - Condor XL
™
MAINTENANCE
ENGINE COOLANT
CAUTION!
Do not remove the radiator cap when the engine is hot.
To check the engine coolant level, open and prop the Engine Cover (3) and observe the coolant level in the Coolant Overfl ow Tank (6). If the level is
low, add a 50/50 mix of water and the recommended type antifreeze. Clean the radiator and oil cooler exteriors by washing with low-pressure water
or using compressed air every 150 hours. Service Note: The oil cooler tips out for easy cleaning.
ENGINE AIR FILTER MAINTENANCE
Check the Engine Air Filter Service Indicator (5) before each use of the machine. Do not service the air fi lter unless the red fl ag is visible in the
service indicator.
CAUTION!
When servicing the engine air fi lter elements, use extreme care to prevent loose dust from entering the engine. Dust can severely
damage the engine.
The engine air fi lter contains a Primary (outer) and a Safety (inner) fi lter element. The Primary Element can be cleaned twice before being replaced.
The Safety Element should be replaced every third time that the Primary Filter Element is replaced. Never attempt to clean the Inner Safety Element.
To clean the Primary Filter Element, unsnap the two clips at the end of the air fi lter and remove the end housing. Pull the primary element out. Clean
the element with compressed air (maximum pressure 100 psi) or wash it with water (maximum pressure 40 psi). DO NOT put the element back into
the canister until it is completely dry.
To Next Page
Loading...
Need help?
General
