FORM NO. 56043124 - Condor XL
™
- 27
ELECTRICAL SYSTEM
FAULT CODE SYSTEM DIAGNOSTICS
The following table describes the systems that are disabled for each fault code. This is included to assist the technician in understanding the ma-
chine response to a specifi c fault code status.
Note: “X” means the corresponding machine system is disabled (turned off).
Display
Code
Fault Description
Recovery
System
Scrub
System
Solution
System
Chemical
System
Side Scrub
System
Side Sweep
System
Side Mist
System
Recycle
System
00 Solution pump(s) M4 and M6 over current x x x
01 Scrub brush pressure valve solenoids over current
(L5andL7)
x x x
02 Main power relay K1 over current x x x x x x x x
03 Wash hose pump M8 over current
04 Dust guard mist pump M5 over current x
05 No speed input 2200 RPM @ ECM
06 No speed input 2400 RPM @ ECM
07 Main solution solenoid valve L10 over current x x
08 RT side scrub solution solenoid L11 over current x
09 Vacuum fan solenoid L1 over current x x x x
10 Not used
11 Squeegee UP solenoid L3 over current x x x x
12 Squeegee DN solenoid L2 over current x x x x
13 Scrub motor solenoid L4 over current x x x
14 Glow plug relay K4 coil over current
15 Scrub cylinder lock solenoid L6 over current x x x
16 RT side scrub/sweep motor solenoid L8 over
current
x x
17 Back Up alarm over current
18 RT side scrub lift cylinder solenoid L9 over current x
19 Horn over current
20 Left turn signal lamp over current
21 Right turn signal lamp over current
22 Head and tail lamp over current
23 Left stop lamp over current
24 Right stop lamp over current
25 20A circuit breaker CB1 over current
26 20A circuit breaker CB2over current
27 15A circuit breaker CB3 over current
28 20A circuit breaker CB4 over current
29 10A circuit breaker CB5 over current
30 Side sweep lift M7 actuator over current x
31 #1 Chemical pump M10 over current (AXP) x
32 #2 Chemical pump M11 over current (AXP) x
33 Engine hot fault (diesel) x x x x x x x x
34 Hydraulic oil temperature fault
35 Low voltage fault (battery)
36 Service engine fault GM (non critical)
37 Low oil pressure (diesel engine) x x x x x x x x
38 Engine fault (critical) x x x x x x x x
39 Hydraulic filter fault (plugged)