PREVOST X3-45 2016 - Page 189

Section 07: TRANSMISSION
PA1593
9
TABLE 1
Recommended Fluid and Filter Change Intervals Using Dexron-III / Non-TranSynd
TM
/Non-TES 295/Mixture
Severe
3
All vehicles equipped with a retarder and not using High-Capacity Filters
Fluid Filters
Main Internal Lube/
Auxiliary
12,000 Miles
(20 000 km)
6 Months/
500 Hrs
12,000 Miles
(20 000 km)
6 Months/
500 Hrs
Overhaul 12,000 Miles
(20 000 km)
6 Months/
500 Hrs
TABLE 2
Recommended Fluid and Filter Change Intervals
1
Using 100% TranSynd
TM
/TES 295 Approved Fluid
2
Severe
3
All vehicles equipped with a retarder and not using High-Capacity Filters
Fluid
Filters
Main Internal Lube/
Auxiliary
50,000 Miles
(80 000 km)
24 Months/
2000 Hrs
50,000 Miles
(80 000 km)
24 Months/
2000 Hrs
Overhaul 50,000 Miles
(80 000 km)
24 Months/
2000 Hrs
TABLE 3
Recommended Fluid and Filter Change Intervals
1
Using 100% TranSynd
TM
/TES 295 Approved Fluid
2
Severe
3
All vehicles equipped with a retarder and using High-Capacity Filters
Fluid
Filters
Main Internal Lube/
Auxiliary
150,000 Miles
(240 000 km)
48 Months/
6000 Hrs
75,000 Miles
(120 000 km)
36 Months/
3000 Hrs
Overhaul 75,000 Miles
(120 000 km)
36 Months/
3000 Hrs
2 inch Control Module (1.75 approximately) – Requires High-Capacity Filter kit Allison P/N 571709
1
Extended TrandSynd™/TES 295 fluid and filter change intervals are only allowed with Allison High-Capacity filters.
2
Less than 100% concentration of TranSynd™/TES 295 approved fluid is considered a mixture and should utilize non-TES 295
change intervals. If the customer replaces non-TranSynd™/non-TES 295 fluid with TranSynd™/TES 295 equivalent, the change
interval recommendations of non-TranSynd™/non-TES 295/mixture must be followed. Upon the next oil change, if the customer
reinstall TranSynd™/TES 295 equivalent, the fluid & filter change recommendation outlined in 100% TES 295 approved fluids must
be followed.
3
Severe vocation= All retarder, On/Off highway, transit and intercity coaches with duty cycle greater than one (1) stop per mile.