Rotax 912 Series Service Manual

00-00-00
Effectivity 912/914 Series
Edition 1 / Rev. 0
page 9
May 01/2007
d02620
BRP-Rotax
Maintenance Manual
R
Red boost lamp 76-00-00 / 11
Return to service 00-00-00 / 25, 71-00-00 / 17, 71-
00-00 / 18
Rev counter inspection 74-00-00 / 53
Rev counter drive 72-00-00 / 21
Rev counter, mechanical 72-00-00 / 8
Rod linkage inspection 73-00-00 / 33
Rod linkage inspection 73-00-00 / 33
Roller bearings for F2 removal 72-00-00 / 24
Roller bearings for F3 removal 72-00-00 / 26
Roller bearings for F4 removal 72-00-00 / 27
Rope sheave 78-00-00 / 19
Rotary seal 75-00-00 / 10
Rust damage 74-00-00 / 10
S
Servo motor 78-00-00 / 20
Silastic 00-00-00 / 32
Solenoid valve (3way) 76-00-00 / 12
Special tools 00-00-00 / 38
Special tools and devices 00-00-00 / 38
Sprag clutch 72-00-00 / 15
Sprag clutch dismantling 72-00-00 / 17
Sprag clutch reassembly 72-00-00 / 18
Sprag clutch removal 72-00-00 / 16
Spring, wastegate 78-00-00 / 19
Starting carburetor 73-00-00 / 31
Stator removal and refitting 74-00-00 / 46
Stroboscope 00-00-00 / 37
Suction pump 79-00-00 / 8
Surface damage 71-00-00 / 15, 74-00-00 / 10
T
Table of amendments 00-00-00 / 17
Target pressure reduction 76-00-00 / 8
TCU inspection 76-00-00 / 32
Technical data 71-00-00 / 11, 71-00-00 / 15
Temperature measuring system 71-00-00 / 22, 75-
00-00 / 15, 79-00-00 / 26
Throttle potentiometer calibration 76-00-00 / 31
Throttle potentiometer inspection 76-00-00 / 37
Throttle valve position inspection 76-00-00 / 29, 76-
00-00 / 31
Tightening torques 00-00-00 / 31
Trigger coil kit 74-00-00 / 13
Trigger coil kit replacement 74-00-00 / 44
Trigger coils arrangement 74-00-00 / 8
Turbocharger assembly 78-00-00 / 15
Turbocharger disassembly 78-00-00 / 7
Turbocharger inspection 78-00-00 / 11
turbocharger control 76-00-00 / 28
Turbocharger control system 76-00-00 / 13, 78-00-00
/ 3
Turbocharger control unit 76-00-00 / 3
Type description 71-00-00 / 4
V
Vacuum pump 72-00-00 / 7, 72-00-00 / 10
Vacuum pump drive removal 72-00-00 / 32
Valve guide 72-00-00 / 62
Valve lapping paste 00-00-00 / 34
Valve seats 72-00-00 / 63
Valves 72-00-00 / 64
Very fine emery cloth 00-00-00 / 33
W
Water pump disassembly 75-00-00 / 6
Water pump housing 75-00-00 / 7, 75-00-00 / 13
Water pump housing inspection 75-00-00 / 7
Water pump shaft 75-00-00 / 9
Weights 71-00-00 / 11, 71-00-00 / 12
Winter operation 73-00-00 / 16
Wiring diagrams 74-00-00 / 22
Wiring harness inspection 76-00-00 / 35

Rotax 912 Series Specifications

General

Redline	5800 rpm
TBO	2000 hours
Displacement	1211 cc
Bore	79.5 mm
Stroke	61 mm
Power Output	80 hp (59.6 kW)
Compression Ratio	9.0:1
Fuel Type	Avgas 100LL
Ignition System	Dual electronic ignition
Fuel System	Fuel Injected
Oil System	Dry sump
Engine Type	4-cylinder, horizontally opposed, 4-stroke