Still RCD40 - Page 158

Forward. . . . . . . . . . . . . . . . . . . . . . . . . . . 66
Front wheel change. . . . . . . . . . . . . . . . . 135
Fuel system air bleeding. . . . . . . . . . . . . 125
G
General front view. . . . . . . . . . . . . . . . . . . 26
General rear view. . . . . . . . . . . . . . . . . . . 27
H
Handling gas springs and accumulators. . 16
Hydraulic diagram. . . . . . . . . . . . . . . . . . 157
Hydraulic fluid. . . . . . . . . . . . . . . . . . . . . . 19
I
Ignition device. . . . . . . . . . . . . . . . . . . . . . 59
Impermissible use. . . . . . . . . . . . . . . . . . . . 4
Installing the bottom plate. . . . . . . . . . . . 116
Intended use. . . . . . . . . . . . . . . . . . . . . . . . 3
L
Leaving the truck. . . . . . . . . . . . . . . . . . . . 90
Lifting the truck with a crane. . . . . . . . . . . 39
Lighting and turn indicator switch. . . . . . . 60
Load
transporting. . . . . . . . . . . . . . . . . . . . . . 83
Load centre distance and load capacity. . 73
Location of the decals. . . . . . . . . . . . . . . . 33
Lubricate the lift mast and chains with
chain spray. . . . . . . . . . . . . . . . . . . . . . . 95
M
Maintenance - 3000 hours. . . . . . . . . . . . 110
Maintenance work without special qualifi-
cations. . . . . . . . . . . . . . . . . . . . . . . . . . 103
Maintenance — 1000 hours. . . . . . . . . . . 107
Maintenance — 500 hours. . . . . . . . . . . . 105
Mast specification. . . . . . . . . . . . . . . . . . 145
Modifications to the truck. . . . . . . . . . . . . . . 5
N
Nameplate. . . . . . . . . . . . . . . . . . . . . . . . . 31
O
Oils. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Opening the bonnet. . . . . . . . . . . . . . . . . 114
Operating attachments. . . . . . . . . . . . . . . 71
Operating company. . . . . . . . . . . . . . . . . . 10
Operating the lifting device. . . . . . . . . . . . 70
Operating the service brake. . . . . . . . . . . . 68
Overview of the driver’s compartment. . . . 28
P
Packaging. . . . . . . . . . . . . . . . . . . . . . . . . 22
Parking brake. . . . . . . . . . . . . . . . . . . . . . . 69
Personnel qualifications. . . . . . . . . . . . . . 103
Picking up a load. . . . . . . . . . . . . . . . . . . . 79
Pre-shift checks. . . . . . . . . . . . . . . . . . . . . 41
Production number. . . . . . . . . . . . . . . . . . 30
Prohibition of use by unauthorised persons. 11
R
Rear wheel replacement procedure. . . . . 134
Recommissioning after storage. . . . . . . . . 98
Removing the bottom plate. . . . . . . . . . . 116
Replacing the breather filter. . . . . . . . . . . 138
Replacing the V-belt. . . . . . . . . . . . . . . . 129
Replacing the water trap. . . . . . . . . . . . . 121
Residual dangers. . . . . . . . . . . . . . . . . . . . 14
Residual risks. . . . . . . . . . . . . . . . . . . . . . 14
Reversing. . . . . . . . . . . . . . . . . . . . . . . . . . 66
S
Safety guidelines. . . . . . . . . . . . . . . . . . . . 11
Safety information. . . . . . . . . . . . . . . . . . . 12
active medical equipment. . . . . . . . . . . 12
Driver's field of vision. . . . . . . . . . . . . . 12
Gas springs. . . . . . . . . . . . . . . . . . . . . 12
Non-ionising radiation. . . . . . . . . . . . . . 12
Speed reduction. . . . . . . . . . . . . . . . . . 12
Welding operations. . . . . . . . . . . . . . . . 12
Safety regulations when driving. . . . . . . . . 15
Safety regulations when handing loads. . . 73
Seat belt
Fastening. . . . . . . . . . . . . . . . . . . . . . . 57
Fastening on a steep slope. . . . . . . . . 57
Malfunction due to cold weather condi-
tions. . . . . . . . . . . . . . . . . . . . . . . . . . 58
Releasing. . . . . . . . . . . . . . . . . . . . . . . 58
Seat belt status and performance checks. 42
Stability. . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Start the engine. . . . . . . . . . . . . . . . . . . . . 63
Storage
Recommissioning. . . . . . . . . . . . . . . . . 98
Supply table. . . . . . . . . . . . . . . . . . . . . . . 113
Symbols. . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
Index
148 60128011601 EN - 03/2020