3-52
SECTION 3
Servicing the Batteries
1. Check the electrolyte level in all batteries. If low, fill with distilled water up to
the correct level.
2. Clean the battery.
3. Clean the cell posts connectors and battery box with water.
Charging
To charge the batteries do the following:
1. Check the electrolyte level. If low, fill with distilled water up to the correct
level.
2. Park the vehicle in an approved area for charging and plug the charger in.
3. Allow the charger to cycle completely before unplugging.
Battery Storage
The following pointers will help extend the life of the battery when storing your vehicle for
the winter season:
n Clean and check the electrolyte level and charge level of the battery. Do not
store a battery low in electrolyte or in a low state of charge.
n Recharge a battery not in use every 1 to 2 months.
n If possible, store the vehicle in a cool, dry place.
If the batteries are removed from the vehicle, do not place them directly on the ground,
concrete or solid metal surface. It is recommended to store them on a wooden pallet or
equivalent.
Do not overfill the battery. An overfilled battery may leak acid.
Explosive mixtures of Hydrogen gas are present within battery
cells at all times. Do not work with or charge battery in an area
where open flames (including gas furnace or water heater
pilots), sparks, cigarettes, or any other sources of combustion
are present. Always provide ample ventilation in rooms where
batteries are being charged.
To Next Page
Loading...
