SB80 Work Platform - European 2-1
Section 2
M
ACHINE
P
REPARATION
& O
PERATION
ALL
occupants must wear an approved fall restraint properly attached to designated platform anchorage point. Attach only one fall
restraint to each anchorage point.
NEVER
exceed maximum platform load of 272 kg (600 lbs.) including two (2) occupants.
NEVER
exceed 200 N (45 lbs.) of side force per occupant.
DISTRIBUTE
all platform loads evenly on the platform.
NEVER
operate the machine without first surveying the work area for surface hazards such as holes, drop-offs, bumps, curbs, or
debris; and avoiding them.
OPERATE
machine only on surfaces capable of supporting wheel loads.
NEVER
elevate the machine when wind speeds exceed 12.5 m/sec. (28 mph).
IN CASE OF EMERGENCY
push emergency stop button to deactivate all powered functions.
ALWAYS
close and secure sliding rail after entering platform.
NEVER
exit or enter platform while elevated.
NEVER
use ladders, scaffolding, or other items to gain height; work only from the platform floor.
NEVER
climb down elevating assembly while platform is elevated.
INSPECT
the machine thoroughly for cracked welds, loose or missing hardware, hydraulic leaks, loose wire connections, and dam-
aged cables or hoses before using.
VERIFY
that all labels are in place and legible before using.
NEVER
use a machine that is damaged, not functioning properly, or has damaged or missing labels.
IF ALARM SOUNDS
while boom is elevated, STOP, carefully retract boom and lower platform without rotating. Move machine to a
firm, level surface.
NEVER
attach overhanging loads or use boom as a crane.
NEVER
alter operating or safety systems without manufacturers written consent.
NEVER
charge batteries near sparks or open flame. Charging batteries emit explosive hydrogen gas.
NEVER
replace any component or part with anything other than original UpRight replacement parts without the manufacturer's writ-
ten consent.
NEVER
tow the machine. Transport by truck or trailer only.
AFTER USE,
secure the work platform from unauthorized use by turning both keyswitches off and removing key.
California Proposition 65 Warning
Gasoline and diesel engine exhaust and some of their constituents are known to the State of California to cause
cancer, birth defects, and other reproductive harm.
Warning
All personnel shall carefully read, understand and follow all safety rules, operating instructions, and the Scaffold Industry Associa-
tion’s
Manual of Responsibilities (ANSI A92.5)
before operating or performing maintenance on any Upright aerial work platform
.
N
EVER
operate the
machine within ten feet of
power lines.
THIS MACHINE IS
NOT INSULATED
.
NEVER
operate boom with
platform elevated unless on
firm level surface (Plus3
machines 3 Degrees).
NEVER
position the plat-
form without first checking
for overhead obstructions or
other hazards.
NEVER
Climb, stand or sit
on platform guardrails or
midrail.
Safety Rules
To Next Page
Loading...