Battery
Battery Operation Warning
Symbols and Their Explanations
1. Be sure to wear goggles during
maintenance!
2. As the battery electrolyte is highly
corrosive, protective gloves and
goggles must be worn during
operation!
3. Open flame, spark, no shade lamps
and smoking are prohibited in the
workplace!
4. Explosive gas mixture will be
generated during battery charging!
5. Keep children away from
electrolyte and battery!
If you are unfamiliar with the repair processes or have
no required tools, be sure to NOT perform any
maintenance on the electrical system of the vehicle.
Without absolute certainty, the work should be
carried out by the authorized dealership of BAIC
ORV.
There is a danger of injury, corrosion, accident
or fire in the maintenance of vehicle batteries
and electrical parts!
● Do not allow acidic or lead-containing
particles to fall into your eyes, on your skin
or on your clothes.
● The acid in the battery is strongly corrosive,
and it is necessary to wear protective gloves
and glasses. Do NOT turn batteries.
Otherwise, the acid inside will flow out of
their exhaust hole. If acid splashes into the
eyes, rinse immediately with a large amount
of clean water and see a doctor immediately.
If battery acid is splashed onto the skin or
clothes, be sure to immediately use a dense
soap liquid to neutralize it and then use a
large amount of water to wash it. If the acid
is swallowed by mistake, be sure to
immediately go to see a doctor.
● The battery will produce explosive gas
mixtures during charging. Therefore, the
battery shall be stored in a well-ventilated
place during charging.
● No open flame, spark, bright light and
smoking. When handling power cables and
electrical equipment and removing static
loads, it is necessary to prevent sparks from
being generated. Do NOT make the battery
terminals short-circuit. Otherwise, the high-
energy sparks generated in the short-circuit
may harm the maintenance personnel.
● When removing the battery, first remove
cables on the cathode, and then the anode.
● Keep children away from acid and battery.
● Turn off all electrical devices before
switching on the battery again. Connect the
positive cable first and then the negative
cable. Do NOT connect the power cables in
the wrong way. This may cause fire!
● Do not remove or install the battery without
permission. In some cases, this will cause
serious damage to the battery and fuse box.
Please contact the authorized dealership of
BAIC ORV if necessary.
To Next Page
Loading...
