Battery charging and battery
replacement
Only when you possess the essential professional
knowledge should you perform maintenance on the
battery.
If the vehicle is frequently driven over short distances
or is parked and not used for a long time, be sure to
increase the frequency of battery checks between the
specified maintenance cycle.
In the event of battery damage, the battery power will
be insufficient, making it difficult to start the vehicle.
If this happens, it is recommended that the battery
shall be recharged or replaced by the authorized
dealership of BAIC ORV and the intelligent battery
sensor shall be re-matched
Only the electrical devices confirming to the
national electromagnetic compatibility
specifications and approved by BAIC ORV can
be used.
Battery charging
If the battery has been used for a rather long time, it
may not maintain charging efficiency when it is
completely new. If the vehicle is used too
infrequently, or the vehicle makes too many short
starts, or runs in a cold environment, then its battery
needs to be charged regularly.
Before charging, be sure to check the state of the
battery.
● Do not charge the battery when it is
connected to the vehicle. This may seriously
damage the electrical system of the vehicle.
● If the battery monitor indication is colorless,
do not attempt to charge the battery.
● Do not attempt to charge the battery if the
battery freezes.
During charging, the battery will produce corrosive
acidic volatile gases and generate currents that can
cause serious damage. Therefore, the following
precautions shall be taken during charging:
● It is necessary to disconnect the terminal from the
vehicle and remove the battery before charging.
Charging the battery that are connected to cables
will damage the electrical system of the vehicle.
● Before turning on the charger switch, make sure
that the battery charger cable is securely clamped
to the terminal of the battery. Do not move the
cable once the charger is turned on.
● Protect your eyes during charging.
● Keep good ventilation around the top of the
battery and avoid strong light near the battery (the
battery will produce flammable hydrogen before
and after charging). When the color in the battery
monitor indication window shows green, please
stop charging, otherwise the battery will be
overcharged.
● Turn off the battery charger before disconnecting
the wire from the battery terminal after charging.
To Next Page
Loading...
