Branson Emerson 2000X aed - Page 7

1019572 REV. 03 vii
List of Figures
Chapter 1: Safety and Support
Figure 1.1 Safety label shown on the top of the 2000X aed Actuator. . . . . . . . . . . . . . . . . . . . .3
Figure 1.2 Connector label on the 2000X aed Actuator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3
Figure 1.3 Caution label on the 2000X aed Actuator for the factory air supply . . . . . . . . . . . . . .3
Figure 1.4 Safety Labels on front of the 2000X aed Actuator . . . . . . . . . . . . . . . . . . . . . . . . . .4
Figure 1.5 CE Mark . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
Chapter 2: Introduction to the 2000X aed Actuator
Figure 2.1 Left Side View of the 2000X aed Actuator. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Figure 2.2 Left Side View of the 2000X aed 15 kHz Actuator . . . . . . . . . . . . . . . . . . . . . . . . . 19
Chapter 3: Delivery and Handling
Chapter 4: Installation and Setup
Figure 4.1 Linear Encoder is Sensitive; Do Not Handle It! . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Figure 4.2 Unpacking the Stand (Actuator on a Base); Left-side View of Stand . . . . . . . . . . . . 38
Figure 4.3 Unpacking the Stand (Actuator on a Base) and Left-side View of Stand of the
2000X aed 15 kHz Actuator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Figure 4.4 Unpacking the Stand (Actuator on a Hub); Hub Shown Separately . . . . . . . . . . . . . 40
Figure 4.5 Ultrasonic Converter (J-Type for Stand-Alone Use) and Booster . . . . . . . . . . . . . . . 41
Figure 4.6 Power Supply Dimensional Drawing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Figure 4.7 2000X Actuator Dimensional Drawing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
Figure 4.8 2000X aed 15 kHz Actuator Dimensional Drawing . . . . . . . . . . . . . . . . . . . . . . . . . 49
Figure 4.9 Block Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Figure 4.10 Base Mounting Centers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Figure 4.11 Base Mounting Centers Dimensional Drawing for 2000X aed 15 kHz Actuator . . . . . . 53
Figure 4.12 Mounting Bolt Pattern for the Hub (for Stand on Hub) . . . . . . . . . . . . . . . . . . . . . . 54
Figure 4.13 Rear view of Actuator, showing Mounting Surface, Bolt and Guide Pin locations . . . . 56
Figure 4.14 Rear view of Actuator, showing Mounting Surface, Bolt and Guide Pin locations for
2000X aed 15 kHz Actuator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57
Figure 4.15 Connections on Rear of Power Supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Figure 4.16 Electrical Connections from Power Supply to a 2000X-series Actuator . . . . . . . . . . . 60
Figure 4.17 Start Switch Connection Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
Figure 4.18 User I/O Cable Identification and Wire Color Diagram . . . . . . . . . . . . . . . . . . . . . . 63
Figure 4.19 Line Cord Color Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Figure 4.20 Actuator Emergency Stop Button. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Figure 4.21 Detail of Rack Mount Handle Kit Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68
Figure 4.22 Assembling the 20 kHz Acoustic Stack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Figure 4.23 Connecting Tip to Horn . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Figure 4.24 Installing a 20 kHz Stack in a Branson Actuator . . . . . . . . . . . . . . . . . . . . . . . . . . 75
Figure 4.25 Installing a 15 kHz Stack in a Branson Actuator . . . . . . . . . . . . . . . . . . . . . . . . . . 75
Figure 4.26 Installing a 40 kHz Stack in a Branson Actuator . . . . . . . . . . . . . . . . . . . . . . . . . . 76
Figure 4.27 Mounting Circles on Base . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Figure 4.28 Normal Front Panel Display After Power-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
Chapter 5: Technical Specifications
Figure 5.1 2000X Actuator Pneumatic System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Chapter 6: Operation