SECTION 3 − DUTY − INDUSTRIAL APPLICATION MOTORI
85
ED. FEBUARY 2003
ANOMALY POSSIBLE CAUSE REMEDY NOTE
Theenginedoesnotstart Battery flat or faulty. Check and recharge battery. Replace bat-
tery if necessary.
Connections to battery terminals cor roded
or loose.
Clean, examine and tighten the nuts on the
battery ter minals. Replace the cable ter-
minals and the nuts if excessively corroded.
Incorrect timing of injection pump. Check and correctly t ime th e injection
pump.
See your dealer.
Deposits or water in the fuel tank. Disconnect the hoses and clean them using
a jet of compressed air.
Dismantle an d clean the injection pump. Re-
move water from tank and refuel.
Drain f eed system.
No fuel in tank. Refuel.
No power supply. Overhaul or replace the fuel or transfer
pump.
Air bubbles in the fuel lines or injection
pump.
Check the hoses to ensure that air is in fact
present and also check the fuel pump. Elim-
inate the air from the injection pump by un-
screwing the cap and working the fuel pump
by hand.
Faulty starter motor. Repair or replace the starter motor.
To Next Page
Loading...
