Farmtrac 6050 E - Page 61

LUBRICATION AND MAINTENANCE CHART
54
The numbers in these column refer to the Operation Numbers contained in the following pages of this section. In
some instances, illustrations are not considered necessary in order to carry out the service operation and are
therefore omitted.
S.No. Items
Interval
10 50 300 600 900 1200 1500
1
Engine Oil level
Check and
refill
ü
2 Radiator Coolant level
Check and
refill
ü
3
Dry Air cleaner dust
collector
Check and
clean
ü
After every 10 hrs.
4
Radiator matrix
Check and
Clean
ü
5
Dry air cleaner primary
element
Check and
Clean
ü After every 10 hrs.
Check and
Clean
ü ü ü ü ü ü At Every Service
6
Greasing Lubricate
ü ü ü ü ü ü
7
Front and rear wheel
nut
Check and
adjust
ü ü ü ü ü ü
8
Battery Electrolyte
level
Check and
adjust
ü ü ü ü ü ü
9
Clutch and brake pedal
free play adjustment
Check and
adjust
ü ü ü ü ü
10
Engine oil Replace
ü ü ü ü ü Every 300 hrs
11
Transmission oil Replace
ü
ü
First 300 hrs then after
every 1200 hrs
Front axle oil Replace ü ü
First 300 hrs then after
every 1200 hrs
13
Power steering oil Replace ü
Every 300 hrs
14
15
Engine oil Filter Replace
ü ü ü ü ü ü At Every Service
16
Fuel filter Replace
ü ü ü ü ü Every 300 hrs
17
Hydraulic oil filter Replace
ü ü ü ü ü ü At Every Service
19
Dry Air cleaner outer/
primary element
Replace ü Every 900 hrs.
20
Dry Air cleaner
inner/secondary
element
Replace
After replacing
primary/outer element 3
times
Indication on hour meter
Lubrication and Maintenance Chart
FARMTRAC (FT 6050 NETS)
After every 10 hrs.
After every 10 hrs.
After every 10 hrs.
ü
ü
At Every Service
At Every Service
At Every Service
At Every Service
18
Hydraulic strainer
Note : General maintenance are the daily prechecks to be carried out before operating the tractor
General Maintenance
Fuel tap strainer
ü ü ü ü ü ü At Every Service
Check & Clean
ü ü ü ü
Power Steeering Oil
Breather
Turbo oil filter
Fan/Alternator belt tension
Replace
ü ü ü ü üü
At Every Service
ü ü ü ü üü
At Every Service
Check and
adjust
12
21
22
23
Replace
ü
First 300 hrs then after
every 1200 hrs
ü