Gehl 5625SX User Manual

ENGINE
Ii
PROBLEM
POSSmLE CAUSE
REMEDY
Engine will not turn
Battery Terminals or Cables corroded or Clean Battery Terminals and Cables and
over.
loose. secure them tightly.
i
Battery discharged or defective.
I
Recharge or replace Battery.
I
Starter Solenoid not Functioning. Troubleshoot circuit per wiring
diagrams to locate trouble and repair or
I
replace Starter Solenoid.
I
Seat or Restraint Bar Switch Sit on Seat and lower Restraint Bar. If
Malfunctioning. Engine still doesn't start, contact your
Gehl Dealer for assistance.
Wiring to and from Ignition, Seat Check wiring for poor connections or
Switch, Restraint Bar Switch, etc ... is broken leads and repair wiring or
loose or disconnected. connection.
Starter or Pinion faulty. Remove Starter and repair or replace
as
I
needed.
Engine turns over but
I
Engine turns over too slow. Check Battery charge. If after being
will not start.
recharged it still does not hold a charge,
replace it.
Engine cranking speed too slow. Battery requires recharging or,
in cold
temperatures, pre-warm the Engine and
Hydraulic oils.
Fuel Tank empty. Check for faulty Fuel Gauge Sender or
I
refill Fuel Tank.
I
QGS malfunctioning. Check connection and voltage, replace
if needed.
Fuel Shut-off Solenoid not energizing. Check electrical connections and
voltage to shut-off Solenoid.
Engine and/or fuel not warm enough. Cycle glow plugs or check glow plug
wiring connections.
Ambient Temperature is too low. Install a Block Heater.
Fuel Pump not working. Contact your Perkins Engine Service
I
I
Center.
Air or moisture
in the Fuel Line. Bleed system per details in the Engine
Manufacturer's manual.
51

Gehl 5625SX Specifications

General

Brand	Gehl
Model	5625SX
Category	Compact Loader
Language	English