Grove RT9130E - List of Specifications; Dimensions; Capacities; Torque Converter

Published 08-25-09, Control # 077-04 1-1
RT9130E SERVICE MANUAL INTRODUCTION
1
GROVE
SECTION 1
INTRODUCTION
DESCRIPTION
This Manual provides information for the maintenance of the
Model RT9000E Series Grove Crane.
The lift capacities are listed on the Load Chart in the cab.
The crane incorporates an all welded parallel box
construction steel frame, using planetary drive axles to
provide four-wheel drive. Axle steering is accomplished
utilizing hydraulic steer cylinders. The engine is mounted at
the rear of the crane carrier and provides motive power
through a six speed forward and a three speed reverse
transmission. Hydraulic, double box, and sliding beam
outriggers are removable.
The carrier frame incorporates an integral fifth wheel, to
which the rear axle is mounted, to provide axle oscillation.
Axle oscillation lockout is automatic when the superstructure
rotates from the travel position.
The superstructure is capable of 360 degree rotation in either
direction. All crane functions are controlled from the fully-
enclosed cab mounted on the superstructure. The crane is
equipped with a five-section, full power, sequenced and
synchronized boom. Additional reach is obtained by utilizing
an optional swingaway boom extension. Lifting is provided
by a main hoist and an optional auxiliary hoist.
NOTE: Throughout this manual, reference is made to left,
right, front, and rear when describing locations.
When operating the crane, these reference
locations are to be considered as those viewed
from the operator’s seat with the superstructure
facing forward over the front of the carrier frame.
NOTE: The Transportation and Lifting Data Decal is shown
in (Figure 1-1). Basic nomenclature is shown in
(Figure 1-2).
LIST OF SPECIFICATIONS
General
Model . . . . . . . . . . . . . . . . . . . . . . RT9000E Series
Rated Capacity. . . . . . . . . . .See Load Chart in cab
Drive. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 x 4 x 4
Gross Weight . . . . . . . . . . . . . . . . See Axle Weight
. . . . . . . . . . . . . . . . . . . . . . . . . . . Distribution Table
Dimensions
NOTE: Dimensions listed are for a crane with all
components fully retracted in the travel mode with
33.25 x 29 tires.
Wheelbase . . . . . . . . . . . . . . . . 4940 mm (194.5 in)
Overall Crane Length . . . . . . . . 16,484 mm (649 in)
Overall Crane Width. . . . . . . . . 3797 mm (149.5 in)
Overall Crane Height . . . . . 4172 mm (164 in) (Std)
. . . . . . . . . . . . . . . . . . . . . . 4089 mm (161 in) (Opt)
Tail-Swing . . . . . . . . . . . . . . . . 4331 mm (170.5 in)
Outrigger Spread
Retracted . . . . . . . . . . . . . . . 3.56 m (11 ft 8 in)
Mid Extend . . . . . . . . . . . . . .6.02 m (19 ft 9 in)
Fully Extended . . . . . . . . . .8.49 m (27 ft 10 in)
Capacities
Fuel Tank . . . . . . . . . . . . . . . . . . 378 liters (100 gal)
Coolant System . . . . . . . . . . . . . . . . . . See Engine
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .Specifications
Engine Lubrication System . . . . . . . . . See Engine
Specifications
Hydraulic Tank (Reservoir Capacity)
Total . . . . . . . . . . . . . . . . . 1363 liters (360 gal)
at Full Level . . . . . . . . . 1226 liters (324.1 gal)
at Low Level . . . . . . . . . 1176 liters (310.6 gal)
Expansion Space . . . . . . . . 51 liters (13.5 gal)
Hoists. . . . . . . . . . . . . . . . . . . . . . . .21 liters (22 qt)
Swing Gearbox . . . . . . . . . . . . . . .5 liters (5-1/4 qt)
Axle Planetary Hubs . . . . . . . . . . . . 11 liters (12 qt)
Axle Differentials . . . . . . . . . . . .27-1/2 liters (29 qt)
Transmission (Includes Torque Converter)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .32 liters (34 qt)
Torque Converter
Stall Ratio. . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.29:1
Charge Pump Capacity . . . . . 117.3 l/min (31 gpm)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . @ 2000 rpm
Transmission
Gear Ratios:
Forward
1st. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7.87
2nd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.94
3rd. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.98
4th. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.25
5th. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.95
6th. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.73
Reverse
1st. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7.87
2nd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.98
3rd. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.95
Engine
Cummins QSC
HP Rating . . . . . . . . . . . . . . . . 300 hp @ 2200 rpm
Peak Torque. . . . . . . . . . 1000 pounds @ 1400 rpm
Lube Amount . . . . . . . . . . . . . . . . 19.9 liters (21 qt)
Coolant System . . . . . . . . . . . . . . 34.1 liters (36 qt)
Axles
Total Ratio (w/differential lock) . . . . . . . . . . . 33.43:1
Total Ration (standard). . . . . . . . . . . . . . . . . 31.94:1
Carrier Ratio (w/differential lock) . . . . . . . . .6.429:1
Carrier Ratio (standard) . . . . . . . . . . . . . . . . 6.143:1
Planetary Ratio . . . . . . . . . . . . . . . . . . . . . . .5.20:1