Coil in starter coil
is broken or
shorted.
Check wiring in electrical
starter control system
Contact of
starting relay is
burnt or injured.
Disassemble starter motor and
make the following
inspections：
1. Check if the carbon brush is
over worn;
2. Check if carbon brush spring
is broken or weak.
3. Check if armature
commutator is over worn.
4. Check if armature coil is
broken or shorted.
1.Check if contact inside clutch
switch is poorly contacted;
2. Check if starter button contact is
poorly contacted;
3. Check if rectifier diode is
damaged;
4. Check if neutral gear switch works
abnormally;
5. Check if wiring of electrical starter
system is broken or shorted.
Check if starting button
contact is poorly contacted
Grasp brake handle and check
if braking lamp is on.
Inner contact of brake lamp switch is
poor contacted or matched wire is
broken.
Repair or replace
starter button.
Wiring of electrical starting system
is broken or shorted.
To Next Page
Loading...
