SAME SOLARIS 55 - Lubricants and Fluids

To Next Page

To Previous Page

SECTION V MAINTENANCE

Lubricants and fluids

PRESCRIBED LUBRIFICANTS AND FUELS SOLARIS 35 - 45 - 55

Main Page

Preface2
- Table of Contents3
Important10
SECTION 1 - Safety15
Aword to the Operator16
Introduction to Safety16
- Safety16
- A Word to the Operator16
- Danger, Warning, Caution16
Danger, Warning, Caution18
- Follow a Safety Programme18
  - For Safe Operation18
- General Safety Rules18
Follow a Safety Programme18
General Safety Rules24
- Protective Structures24
  - Roll over Protective Structures24
  - Operation24
Protective Structures24
Damage to the ROPS25
- Cab25
Cab26
- Prepare for Safe Operation26
Prepare for Safe Operation26
Servicing the Tractor31
- Starting31
- General Operating Hazards39
Starting31
General Operating Hazards40
- Safety and Operational Decals46
- International Symbols (Part. 1)58
International Symbols (Part. 1)59
- International Symbols (Part. 2)59
International Symbols (Part. 2)60
- International Symbols (Part. 3)60
International Symbols (Part. 3)61
- Metric Conversion61
Metric Conversion62
- Conversion Tables62
SECTION 2 - Replacement Parts65
- Tractor Serial Number65
Tractor Serial Number66
- Engine Serial Number66
- Tractor Identification Plate66
Engine Serial Number66
Tractor Identification Plate67
- Original Replacement Parts67
SECTION 3 - Use69
- Checking the Tractor Prior to Starting Work69
  - Refuelling70
  - Checking the Engine Oil Level71
Checking the Tractor Prior to Starting Work70
- Access to the Driving Position72
Access to the Driving Position73
- Lights' Switch73
Lights' Switch74
- Instrument Panel74
Instrument Panel75
- Ignition Switch80
Ignition Switch81
- Engine81
  - Precautions for Optimum Engine Performance81
- Starting the Engine83
  - Electronic Control of Engine Cooling System84
Engine81
Starting the Engine84
- Engine Shut down85
Engine Shut down86
- Cold Starting86
Cold Starting87
- Emergency Starting through Auxiliary Battery87
Emergency Starting through Auxiliary Battery88
- Turbocharging88
Turbocharging89
- Manual Emergency Stop89
Manual Emergency Stop90
- Adjusting the Driver's Seat90
  - BOSTROM Minibaltic XH2 Seat with Spring Suspension90
  - KAB P4 XH2 Sprung Seat91
- Adjusting the Rearview Mirrors93
Adjusting the Driver's Seat90
Adjusting the Rearview Mirrors94
- Control Pedals94
- Gearbox Controls99
  - Transmission Speed Selection100
Control Pedals94
Gearbox Controls100
- Front and Rear Differential Lock101
Front and Rear Differential Lock102
- Front-Wheel Drive102
Front-Wheel Drive103
- Power Take-Off103
Power Take-Off104
- Load Sensing - Mechanical Lift109
  - Controls110
  - Hydraulic System114
Load Sensing - Mechanical Lift110
- Auxiliary Hydraulic Services Control Valve117
Auxiliary Hydraulic Services Control Valve118
- Nomenclature118
- Types of Auxiliary Hydraulic Service Control Valve119
- The Controls120
- Example Connection and Operation of a Double-Acting Cylinder122
- Connection of an Implement to the Auxiliary Hydraulic Service Couplers123
- Converting a Control Valve from Double-Acting to Single-Acting126
- Example of Connection to a Single-Acting Cylinder127
Class "A" Drawbar128
- Towing Hitch129
Towing Hitch130
- Class "C" Towing Hitch130
- CEE Towing Hitch131
CEE Towing Hitch133
- Three-Point Linkage133
Three-Point Linkage134
- Hydraulic Front Lift137
  - Bodywork139
  - Safety Frame140
Hydraulic Front Lift139
- Cab142
Cab143
- Active Carbon Air Filter153
Active Carbon Air Filter154
- Cable Channel for Passing External Implement Control154
- Cables into the Cab154
- Hazard Warning Triangle154
- Screen Wash Liquid Reservoir154
SECTION 4 - Wheels155
- Track Adjustment155
- Tyre Inflation Pressures156
- Width of the Front Axle (Without Wheels)157
- Mechanical Ratio (Front Wheel Revolutions / Rear Wheel Revolution)157
- Width of Rear Axle (Without Wheels)157
- Row Crop Tires157
- Running Direction of Tires158
- Adjusting Steering Stops158
- Adjustable Track Wheels159
- Permissible Tyre Combinations160
Track Width Adjustment for Wheels with Adjustable Rims161
- Track Width Adjustment for Wheels with Fixed Rims168
Track Width Adjustment for Wheels with Fixed Rims169
- Ballast169
Ballast169
SECTION 5 - Maintenance Operations173
- Lubricants and Fluids175
Lubricants and Fluids176
- Maintenance Intervals176
Maintenance Intervals178
- Maintenance and Inspection Schedule178
Maintenance and Inspection Schedule181
- Fuel Storage181
  - Refueling181
  - Refueling at the End of the Day182
- Engine Maintenance183
Fuel Storage181
Engine Maintenance184
- Air Filter194
Air Filter195
- Cleaning the Air Filter195
Cleaning the Air Filter197
- Engine Cooling System197
- Adjusting Belt Tension200
Engine Cooling System197
Adjusting Belt Tension201
- Gearbox Clutch201
- Rear and Underside P.T.O. Clutch201
Gearbox Clutch201
Rear and Underside P.T.O. Clutch202
- Maintenance of the Gearbox, Differential and Rear Reduction Units202
  - Checking the Transmission Oil Level204
  - Changing the Oil205
Maintenance of the Gearbox, Differential and Rear Reduction Units204
Maintenance of the Hydrostatic Power Steering206
- Checking Operation of the Differential Lock Controls207
Checking Operation of the Differential Lock Controls208
- Maintenance of the Front and Rear Brakes208
  - Checking the Braking Action208
- Front Differential Lock (if Installed)208
Maintenance of the Front and Rear Brakes208
Front Differential Lock (if Installed)209
- Maintenance of the Front Wheel Drive System209
  - Front Axle and Hub Final Drives (4WD)209
  - Front Axle Pivot Bushes209
Maintenance of Hydraulic Power-Lift211
- Maintenance of the 3-Point Linkage211
  - Rear 3-Point Linkage211
- Maintenance of Front P.T.O212
Maintenance of the 3-Point Linkage211
Maintenance of Front P.T.O.213
- Maintenance of Front Lift213
Maintenance of Front Lift214
- Windscreen Washer214
- Windscreen and Rear Screen Wipers214
Windscreen Washer214
Windscreen and Rear Screen Wipers215
- Maintenance of the Air Conditioning System215
  - Cab Air Filter (Cleaning)215
  - Active Carbon Air Filter215
- Maintenance of the Heating System216
Maintenance of the Air Conditioning System215
Maintenance of the Heating System217
- Maintenance of the Air Conditioning System217
Maintenance of the Air Conditioning System217
General Cleaning of the Tractor220
- Cleaning with Compressed Air220
Cleaning with Compressed Air221
SECTION 6 - Electrical System221
- Battery221
  - Checking the Battery221
- Fuse Box223
Battery221
Fuse Box226
Cab Fuse Box232
Lights236
- Headlight Alignment241
Headlight Alignment242
- Horizontal Adjustment242
- Vertical Adjustment242
SECTION 7 - Storage of the Tractor243
- Operations Prior to Garaging the Tractor for a Long Period243
Operations Prior to Garaging the Tractor for a Long Period244
- Preparing the Tractor for Use after a Long Period of Storage244
Preparing the Tractor for Use after a Long Period of Storage245
SECTION 8 - Technical Specifications245
- Engine245
Engine246
- Clutch246
- Power Take-Off246
Clutch246
Power Take-Off248
- Gearbox248
Gearbox249
- Gearbox Ratios Schematic249
Gearbox Ratios Schematic250
- Performance - Ground Speed in Km/H (Mph) @ 3000 Rpm250
Performance - Ground Speed in Km/H (Mph) @ 3000 Rpm252
- Front Driving Axle252
- Hydrostatic Steering System252
- Front Hydraulic Lift252
Front Driving Axle252
Hydrostatic Steering System252
Front Hydraulic Lift253
- Hydraulic Diagram of Lift253
Hydraulic Diagram of Lift254
- Hydrostatic Steering System254
- Cab254
Hydrostatic Steering System254
Cab255
- Dimensions and Weights255
Dimensions and Weights256
- Unladen Weight of Tractor (Without Ballast)256
- Unladen Weight of Tractor (with Ballast)256
Unladen Weight of Tractor (Without Ballast)256
Unladen Weight of Tractor (with Ballast)257
- Maximum Permissible Loads257
- Maximum Trailerable Loads257
- Ballast Weights257
Maximum Permissible Loads257
Maximum Trailerable Loads257
Ballast Weights258
- Attachment of Implements to the Tractor258
Attachment of Implements to the Tractor259
- Implement Attachment Points259
Implement Attachment Points263
SECTION 9 - Fault Diagnosis263
- Engine263
Engine265
- Gearbox265
Gearbox266
- Rear Power Take-Off266
- Front Driving Axle266
- Brakes266
- Hydraulic Lift266
Rear Power Take-Off266
Front Driving Axle266
Brakes266
Hydraulic Lift267
- Auxiliary Hydraulic Systems267
Auxiliary Hydraulic Systems269
Appendix269
- Combination of Tractor and Mounted Implement269
Combination of Tractor and Mounted Implement270
- Determination of the Total Weight, the Axle Loads, the Tyre Load Carrying Capacity and the Necessary Minimum Ballasting270
- Consideration of Rear Mounted Implement and Front/Rear Combinations271
- Front Mounted Implement271

SAME SOLARIS 55 - Lubricants and Fluids

Table of Contents

Related product manuals