Steris Basil 4600 - Page 7

vi
Table of Contents Operator Manual 122997-341
TABLE OF CONTENTS (Cont’d)
Section
Number Description Page
2 INSTALLATION CHECKLIST
2-1 Shutoff Valves and Disconnect switch ................................................................................................. 2-1
3 COMPONENT IDENTIFICATION
3-1 Washer Components - Basil 4600 (Typical) ........................................................................................ 3-1
3-2 Control Column ................................................................................................................................... 3-2
3-3 Control Panel ....................................................................................................................................... 3-3
3-4 Printer .................................................................................................................................................. 3-5
3-5 Sample Printout ................................................................................................................................... 3-6
3-6 Sample Alarm Printout ......................................................................................................................... 3-6
3-7 Unload-Side Control Panel .................................................................................................................. 3-7
3-8 Oscillating Jet System ......................................................................................................................... 3-7
3-9 Safety Cables ...................................................................................................................................... 3-8
3-10 Heat Exchanger .................................................................................................................................. 3-9
3-11 Non-Recirculated Final Rinse Spray Header .................................................................................... 3-10
3-12 Drain Discharge Side Tank (Typical) ................................................................................................ 3-12
3-13 Exhaust Fan ....................................................................................................................................... 3-13
4 WASHER OPERATION
4-1 Manual Drain Valve ............................................................................................................................. 4-1
4-2 Accessories ......................................................................................................................................... 4-3
4-3 Manual Control Mode Flow Chart ...................................................................................................... 4-23
5 CYCLE PROGRAMMING
5-1. Program Touch Pads ............................................................................................................................ 5-1
6 ROUTINE MAINTENANCE
6-1. Spray Header Flush Plug ..................................................................................................................... 6-6
6-2. Self-Cleaning Screen ............................................................................................................................ 6-7
6-3. Exhaust Fan Grease Fittings ................................................................................................................ 6-9
6-4. Manual Drain Valve ............................................................................................................................ 6-10
6-5. Replace Squeeze Tube ...................................................................................................................... 6-13
6-6. Replacing Detergent Container........................................................................................................... 6-14
6-7. Printer Paper Roll Replacement ......................................................................................................... 6-16
Figure
LIST OF FIGURES