Contents
2 / 80 GB October 2013
CONTENTS
1 Foreword........................................................ 3
1.1 About these operating instructions............3
1.2 Intended use............................................. 3
1.3 Intentional misuse..................................... 3
1.4 Service...................................................... 3
2 Safety conditions.......................................... 4
2.1 Identification of safety instructions............ 4
2.2 Safety sign................................................ 4
3 Control panel and control............................ 8
3.1 General handling / entry of
parameters................................................ 8
4 Menus........................................................... 10
4.1 Menu Structure....................................... 10
4.2
Menu "Home"..........................................10
4.3 Pictogram................................................ 14
4.4
Menu "Trends"........................................ 14
4.5
Menu "Settings"...................................... 16
4.6
Menu "Fault History".............................. 20
4.7
Menu "Access Code"............................... 20
5 Configuration...............................................22
5.1 Choose Language...................................22
5.2 Inverting the screen output..................... 22
5.3 Setting the date and time........................22
5.4 Setting the measurement units............... 23
5.5 Advanced Settings.................................. 25
5.5.1 Setting the pressure bands.....................25
5.5.2 Programming Inputs and Outputs........... 27
5.5.3 Timer control operation...........................31
5.5.4 Programming dryer pre-run time.............35
5.5.5 Configuring RS484 communication.........36
5.5.6 Setting automatic restart after a power
failure.......................................................37
5.5.7 Setting Remote Start and Stop............... 38
5.5.8 Remote Load and Off-Load (FS)............ 39
6 Operations................................................... 40
6.1 Stopping the compressor in an
emergency...............................................40
6.2 Starting the compressor..........................40
6.3 Start Inhibits............................................ 40
6.4 Operations...............................................41
6.5 Operating Modes.................................... 41
6.6 Water circuit control................................ 41
6.7 Stopping the compressor........................ 42
6.8 Operational monitoring............................42
7 Troubleshooting.......................................... 43
7.1 Troubleshooting check list...................... 43
7.2 How the Fault and Warning Codes are
Structured................................................43
7.3 Troubleshooting.......................................44
8 Advanced operation....................................53
8.1 Maintenance Level..................................53
8.2 Additional maintenance level graph
screens....................................................53
8.3 Resetting the statistics on-load hours..... 54
8.4 Setting the service interval......................54
8.5 Data logging............................................55
9 Setting Up a Replacement Controller........57
9.1 The Setup Code and Compressor
Identification Number.............................. 57
9.2 Setting up a replacement controller........ 57
10 Base Load Sequencing (BLS)....................60
10.1 Base Load Sequencing...........................60
10.2 Supported slave controllers.................... 60
10.3
Menu "Base Load Sequencing"............... 61
10.4 Compressor Status Messages................63
10.5 Compressor settings and information..... 64
10.6 Base Load Sequencing Settings.............65
10.7 BLS function description......................... 67
10.8 Trend and statistics graphs.....................68
10.9 RS485:3 module installation................... 69
10.10 Installing the compressor module
(STD).......................................................70
11 Appendix...................................................... 75
11.1 Status messages.................................... 75
11.2 Settings................................................... 76
To Next Page
Loading...
Need help?
General
