DAF 95XF - 2.2 Overview of annual maintenance activities

MAINTENANCE SCHEDULE
Maintenance activities 95XF series
2-2
2.2 OVERVIEW OF ANNUAL MAINTENANCE ACTIVITIES
ANNUAL MAINTENANCE ACTIVITIES (Y-SERVICE)
”Correct if necessary after inspection”
CAB AND ELECTRICAL SYSTEM
f Check pedal rubbers
f Check headlight setting
f Check fluid level of cab tilting pump
f Check cab fastening
ENGINE, COOLING SYSTEM AND FUEL SYSTEM
f Replace air filter element
f Check/adjust valve clearance- See Note 6 Done f Yes f No
f Check/adjust valve clearance and unit injectors (VF engine)
f Check/adjust C--brake clearance (VF engine)
f Check/adjust DEB clearance
f Clean fuel coarse filter (XE engine)
f Replace coolant filter
f Check antifreeze content of coolant
f Change coolant - See Note 1 Changed f Yes f No
f Check glow plugs - See Note 7
STEERING GEAR AND BRAKE SYSTEM
f Replace steering gear filter element - See Note 8 Replaced f Yes f No
f Check steering ball joints
f Replace air dryer filter element
f Check compressor line
f Check brake cylinder fastening
f Check automatic brake adjuster
f Check/adjust load--dependent control valve
f Check electropneumatic valves of ABS/ASR
f Check attachment of universal joint of steering box input shaft
f Push front axle wheel speed sensors up against pole ring
DRIVE AND CHASSIS
f Check fluid level of trailing axle lifting device
f Check pivot points of trailing axle lifting device
f Change differential oil - See Note 2 Changed f Yes f No
f Change hub oil - See Note 2 Changed f Yes f No
f Check operation of differential lock
f Check drive shaft play
f Change gearbox oil - See Note 3 Changed f Yes
f No
f Change retarder oil (Voith retarder) - See Note 5 Changed f Yes f No
f Replace grease of grease lubricated hubs - See Note 4 Replaced f Yes f No
f Check fifth wheel
f Check trailer coupling
f Check superstructure attachment
OTHER ACTIVITIES
f Check whether there are any field actions that need to be performed on the vehicle.
4
 200424