Danfoss TTS300 User Manual

1.2 Purpose
ThisServiceManualisintendedtoprovideserviceproceduresspecifictotheDanfossTurbocorcompressors.Itisnot
intendedtoteachbasicfundamentalsafety,refrigeration,electrical,orfittingskills.Itisassumedpersonsusingthis
manualwillbeappropriatelycertifiedandhavedetailedknowledge,experience,andskillsinrespecttoworking
withhigh-pressurerefrigerantsandmediumvoltageelectricalcomponentsto1Kilovolt(kV)high-poweralternating
current(AC)anddirectcurrent(DC).
Somepotentialsafetysituationsmaynotbeforeseenorcoveredinthismanual.DanfossLLCexpectspersonnel
usingthismanualandworkingonDanfossTurbocorcompressorstobefamiliarwith,andcarryout,allsafework
practicesnecessarytoensuresafetyforpersonnelandequipment.
Thepurposeofthismanualistoprovide:
l
Ageneraldescriptionofthecompressordesign
l
Afunctionaldescriptionofthevariouscomponentsofthecompressor
l
Informationregardingproceduresnecessarytodetectthesourceofaproblemwithinthe
compressor
l
Theproceduresfordisassemblingandassemblingvariouscomponentsofthecompressor
l
Faultandcalibrationinterpretations
l
Systemtroubleshootingsuggestions
NOTE
Bearingandbearingsensorrepairsarenotcoveredinthismanualastheyarenotfieldserviceable.Compressorsrequiringsuchrepairs
mustbesentbacktothefactoryforinspectionandrepair.

Thismanualgivesonlygeneralproceduresforservicinganddoesnotprovidepartnumbersofsingleproductsor
singlecomponents.Ifthisinformationisrequired,pleasecontactarecognizedDanfossTurbocororiginalequipment
manufacturer(OEM)customer.
Additionally,thismanualiswrittenforMajorrevisionFandlatercompressors.Whennecessary,particularrevision
compressorsarespecified,butthemajorityofthecontentremainsthesame,regardlessofthecompressorrevision.
DanfossLLCdoessellvariousupgradekits(e.g.,SoftStartUpgradeKit)andthosekitsmayincluderetrofitcablingor
otherhardwarethatarenotspecificallyinstalledonproductioncompressors.Thismanualonlyillustrates
componentsthatwereinstalledonproductioncompressors.Alwaysrefertothespecificsparepartkitinstructions
duringinstallation.
1.3 Organization
Thismanualisorganizedinthefollowingmanner:
l
Section 1: Introduction–thissectiondescribesthepurposeofthemanual,itsorganization,
conventionsusedinthemanual,andasafetysummarywhichdescribestheuseofDanger,Caution,
andNotessymbols
l
Section 2: Compressor Fundamentals–thissectionidentifiesthepartsofthecompressorand
providesfundamentalknowledgeoftheroleeachcomponentplaysinthemainfluidpath,motor-
coolingsystem,andintheenergyandsignalflow
l
Section 3: Compressor Removal and Installation–thissectiondescribesthesafepracticesof
removingandinstallingthecompressor
l
Section 4: Compressor Components–thissectiondescribesindepthcomponentinformation,
thestepsnecessarytoobtainmeasurementsthatverifyacomponentisfunctionalandthesteps
necessarytoreplaceacompressorcomponent
M-SV-001-EN Rev. H-1/23/2023 Page 19 of 294

Danfoss TTS300 Specifications

General

Brand	Danfoss
Model	TTS300
Category	Air Compressor
Language	English