CHAPTER 5. TROUBLESHOOTING
121
CHAPTER 5. TROUBLESHOOTING
• Short of grease with collector lift and
dump link
• Install hydraulic hose by mistake
• Too low engine speed
• Defective hydraulic system
Troubles Presumable causes Remedies
The filling rate of container is
poor
Excessive noise and vibration
Collector does not move.
• Net of container is clogged
• Shooter is clogged with grass
• Mower deck is clogged with grass
• Too low engine speed
• Engine power is down or overheat
• Grass is too moisty
• Too tall grass
• Too fast traveling
• Too dense grass
• Adjustment of grass limit sensor is poor
• Damage of blower fun
• Loose bolts and nuts
• Fulcrum of collector link and dump link
is poor
• Cramp of hydraulic hose is loosen
• Short of grease with collector lift and
dump link
• Assembly of rubber washer to the upper
portion of lift cylinder is forgotten.
• Clean
• Clear the clogged grass
• Clear the clogged grass
• Mow at full throttle ( )
• Check engine oil, air cleaner,
coolant and clean radiator net,
fuel filter
• Wait until grass becomes dry
• Try to mow in two steps
• Slow down sufficiently
• Try to mow in two steps
• Adjust it properly
• Consult your dealer
• Inject grease with collector link
and dump link
• Check and correct
• Raise engine speed
• Consult your dealer
• Retighten them properly
• Check and consult your dealer if
necessary
• Cramp it properly
• Inject grease with collector link
and dump link
• Assemble rubber washer
To Next Page
Loading...
