TROUBLE SHOOTING
PROBLEM
CAUSE
REMEDY
REF
.
Engine hard
to
start
or
Diesel: Hand lever on Push lever
dow
n.
72
will not start. (cont'd)
lift
pump
raised.
Crankcase oil
too
Use recommended oil.
46
heavy.
Low battery output. Have battery tested.
79
Check battery electro-
lyte level.
Poor battery Clean and tighten loose
79
connection. connections.
Faulty starter. Repair
or
replace.
*
Wiring shorted, circuit
Check continuity
of
84
breaker open.
wiring and breaker
(manual reset).
Gas engine -
no
spark. Clean
or
replace spark
53
plugs. Check wires.
Check distributor cap
55
and air gap.
Diesel engine - faulty Clean
or
replace
*
injectors. injectors.
Engine knocks.
Insufficient oil. Add oil.
50
,63
Engine out
of
time.
Diesel - Time injection
*
pump.
Gas - Time engine
54
ignition.
Low
or
high coolant
Remove and check
*
temperature. thermostat. See "Engine
Overheats".
Improper fuel. Use proper fuel.
45
Low oil pressure.
Low oil level. Add oil.
50,63
Improper type
of
oil. Drain, fill crankcase with
46
proper oil.
Worn components.
Repair engine.
*
High oil consumption.
Crankcase oil
too
light.
Use recommended oil.
46
Oil leaks.
Check
for
leaks around
gaskets, seals, and
drain plugs.
Internal parts worn.
Check for worn parts.
*
Engine stops.
Operator left seat with
Disengage header drive,
35
controls out
of
neutral. put controls
in
neutral.
* See your Windrower dealer.
118
To Next Page
Loading...
