Manitou MLT 961-145 V PLUS L JD ST4 S1 - Page 115

3 - 7
Ü
1000 HOUR - PERIODIC MAINTENANCE - EVERY 1000 HOURS OF SERVICE OR 2 YEARS
IN ADDITION, CARRY OUT PERIODIC MAINTENANCE FOR 500 HOURS OF SERVICE.
- CHECK Seat belt ........................................................................ 3-28
- REGENERATE "Parked telehandler" exhaust particulate filter .................................... 3-28
- CLEAN Fuel tank ........................................................................ 3-29
- REPLACE Coolant ......................................................................... 3-30
- REPLACE Dry air filter cartridge ............................................................ 3-31
- REPLACE Ventilation circuit in the I.C. engine guard ........................................ 3-31
- REPLACE Front wheel reducer oil .......................................................... 3-31
- REPLACE Rear wheel reducer oil ........................................................... 3-31
- REPLACE Gearbox oil...................................................................... 3-32
- CLEAN Speed sensor .................................................................... 3-32
- CHECK I.C. engine silent blocks *......................................................... 3-33
- CHECK Gearbox silent blocks *........................................................... 3-33
- CHECK Gearbox controls *............................................................... 3-33
- CHECK Brake circuit pressure *........................................................... 3-33
- CHECK Wear of boom pads * ............................................................ 3-33
- CHECK Condition of wiring harness and cables * ......................................... 3-33
- CHECK Lighting and signalling * ......................................................... 3-33
- CHECK Indicators * ...................................................................... 3-33
- CHECK Side rear-view mirror conditions * ................................................ 3-33
- CHECK Cab structure * .................................................................. 3-33
- CHECK Structure of the chassis *......................................................... 3-33
- CHECK Attachment holder table * ....................................................... 3-33
- CHECK Attachment conditions *......................................................... 3-33
- REPLACE Brake oil * ....................................................................... 3-33
- PURGE Brake circuit *.................................................................... 3-33
- ADJUST Brake * .......................................................................... 3-33
* Consult your dealer
Ü
2000 HOUR - PERIODIC MAINTENANCE - EVERY 2000 HOURS OF SERVICE OR 4 YEARS
IN ADDITION, CARRY OUT PERIODIC MAINTENANCE FOR 500 HOURS OF SERVICE AND 1000 HOURS OF SERVICE.
- CHECK Tightening torque of the wheel nuts ............................................. 3-34
- REPLACE Hydraulic oil..................................................................... 3-34
- CLEAN Suction strainer for hydraulic oil tank ............................................. 3-34
- REPLACE Hydraulic oil tank breather....................................................... 3-34
- CHECK Radiator * ....................................................................... 3-36
- CHECK Transmission pressures * ......................................................... 3-36
- CHECK Steering * ....................................................................... 3-36
- CHECK Steering swivel joints *........................................................... 3-36
- CHECK Wear of the brake pads and the brake disk * ...................................... 3-36
- CHECK Boom assembly conditions * ..................................................... 3-36
- CHECK Bearings and articulation rings * ................................................. 3-36
- CHECK Rubber hose pipe and piping conditions ......................................... 3-36
- CHECK Cylinder conditions (leakage, rods) ............................................... 3-36
- CHECK Hydraulic circuit pressures *...................................................... 3-36
- CHECK Bearings and articulation rings * ................................................. 3-36
- CLEAN/CHECK Air conditioning (OPTIONAL)..................................................... 3-36
- REPLACE Compressor belt (OPTIONAL air conditioning) *................................... 3-36
* Consult your dealer
Ü 
3000 HOUR - PERIODIC MAINTENANCE - EVERY 3000 HOURS OF SERVICE OR 6 YEARS
IN ADDITION, CARRY OUT PERIODIC MAINTENANCE FOR 500 HOURS OF SERVICE AND 1000 HOURS OF SERVICE.
- REPLACE Dry air filter safety cartridge...................................................... 3-38
Ü 
4000 HOUR - PERIODIC MAINTENANCE - EVERY 4000 HOURS OF SERVICE OR 8 YEARS
IN ADDITION, CARRY OUT PERIODIC MAINTENANCE FOR 500 HOURS OF SERVICE AND 1000 HOURS OF SERVICE.
- REPLACE DEF (Diesel Exhaust Fluid) feed pump filter ....................................... 3-39