OPERATING CONTROLS AND PROCEDURES RT9130E-2 OPERATOR MANUAL
3-32 Published 3-1-2018, Control # 559-03
Starting Procedure
Make an under-the-hood inspection for fuel, oil, and coolant
leaks, worn drive belts, and trash build-up.
Use the correct grade of oil for the prevailing temperature in
the crankcase to prevent hard cranking. Diesel fuel should
have a cloud point of 6°C (10°F) less than the lowest
expected temperature. In case of emergency, white
kerosene may be added to the fuel to bring the cloud point
down to the required temperature.This will minimize clogging
of filters and small passages by wax crystals. The addition of
kerosene is NOT recommended for general use.
Battery Disconnect Switch
Ensure battery disconnect switch handle (1) (Figure 3-17) is
in the ON position
Cold Engine
NOTE: The engine ECM monitors the engine and, under
certain conditions, cycles the air heater on and off
at start-up and during operation.
The engine is equipped with an electric grid heater at the air
inlet elbow to aid in cold starting and reduce white smoke at
start-up. In the preheat mode, the engine should not be
cranked until the Wait-to-Start Lamp turns off.
1. Prior to starting a cold engine, ensure the Crane
Function switch is positioned to OFF.
Set the parking brake to On.
2. Position the transmission to neutral, and depress the
service brake foot pedal.
CAUTION
Health Hazard!
Diesel engine exhaust can be harmful to your health. Only
operate the engine in a well ventilated area or vent
exhaust outside.
Unexpected Operation Hazard!
Before starting the engine, apply the parking brake and
engage the swing lock.
CAUTION
Avoid Crane Damage!
Do not engage the parking brake while the vehicle is
moving. Damage to the crane can occur.
Disengage the parking brake before driving. Damage to
the crane can occur.
CAUTION
Machine Damage Hazard!
Never crank the engine for more than 30 seconds during
an attempted start. If the engine fails to start after 30
seconds, stop and allow the starter motor to cool for
approximately two minutes before attempting another
start.
If the engine fails to start after four attempts, correct the
malfunction before attempting further starts.
WARNING
Risk of Explosion!
Do not spray starting fluid into the air inlet. The spray will
contact the heater elements and could explode causing
personal injury.
CAUTION
Avoid Crane Damage!
Do not engage the parking brake while the vehicle is
moving. Damage to the crane can occur.
Disengage the parking brake before driving. Damage to
the crane can occur.
To Next Page
Loading...
Need help?
General
