Manitowoc Grove RT9130E-2 - List of Specifications; General; Dimensions; Capacities

Grove Published 3-1-2018, Control # 559-03 1-7
RT9130E-2 OPERATOR MANUAL INTRODUCTION
1
LIST OF SPECIFICATIONS
General
Model . . . . . . . . . . . . . . . . . . . . . . RT9000E Series
Rated Capacity. . . . . . . . . . .See Load Chart in cab
Drive. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 x 4 x 4
Gross Weight . . See Axle Weight Distribution Table
Dimensions
NOTE: Dimensions listed are for a crane with all
components fully retracted in the travel mode with
33.25 x 29 tires.
Wheelbase . . . . . . . . . . . . . . . . 4940 mm (194.5 in)
Overall Crane Length . . . . . . . . .16.48 m (54 ft 1 in)
Overall Crane Width. . . . . . . . . . .3.80 m (12 ft 5 in)
Overall Crane Height 4.172 mm (13 ft 8.25 in) (Std)
. . . . . . . . . . . . . . . . . . . . 4089 mm (13 ft 5 in) (Opt)
Tail-Swing. . . . . . . . . . . . . . . . 4.331 m (14 ft 2.5 in)
Outrigger Spread
Retracted. . . . . . . . . . . . . . . .3.56 m (11 ft 8 in)
Mid Extend . . . . . . . . . . . . . .6.02 m (19 ft 9 in)
Fully Extended . . . . . . . . . .8.49 m (27 ft 10 in)
Capacities
Fuel Tank . . . . . . . . . . . . . . . . . . . . . 378 l (100 gal)
Coolant System . . . . . . . . . . . . See Engine Manual
Engine Lubrication System . . . See Engine Manual
Hydraulic Tank (Reservoir Capacity)
Total. . . . . . . . . . . . . . . . . . . . . 1363 l (360 gal)
at Full Level. . . . . . . . . . . . . .1226 l (324.1 gal)
at Low Level . . . . . . . . . . . . . 1176 l (310.6 gal)
Expansion Space . . . . . . . . . . . .51 l (13.5 gal)
Hoists . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 l (22 qt)
Swing Gearbox. . . . . . . . . . . . . . . . . . . 5 l (5-1/4 qt)
Axle Planetary Hubs. . . . . . . . . . . . . . . . 11 l (12 qt)
Axle Differentials . . . . . . . . . . . . . . . 27-1/2 l (29 qt)
Transmission (Includes Torque Converter)
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 l (34 qt)
Diesel Exhaust Fluid (DEF) . . . . . . . .37.9 l (10 gal)
Torque Converter
Stall Ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . .2.29:1
Charge Pump Capacity . . . . .117.3 L/min (31 gpm)
@ 2000 rpm
Transmission
Gear Ratios:
Forward
1st . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7.87
2nd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.94
3rd. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.98
4th . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.25
5th . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.95
6th . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.73
Reverse
1st . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7.87
2nd . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.98
3rd. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.95
Engine
Cummins QSL or (QSC)
HP Rating 320 (300) hp [239 (224) kw @ 2200 rpm
Peak Torque. 1020 (1000) lb-ft [1383 (1356) Nm @
1500 rpm
Lube Amount . . . . . . . . . . . 22.7 l(18.9 l) [24 (20)qt]
Coolant System . . . . . . . . . . . . . . . . . .34.1 l (36 qt)
Axles
Total Ratio (w/differential lock) . . . . . . . . . . . 33.43:1
Total Ration (standard). . . . . . . . . . . . . . . . . 31.94:1
Carrier Ratio (w/differential lock) . . . . . . . . . 6.429:1
Carrier Ratio (standard) . . . . . . . . . . . . . . . . 6.143:1
Planetary Ratio . . . . . . . . . . . . . . . . . . . . . . . 5.20:1
Brakes
Type . Hydraulic/Split system acting on all four wheels
Size . . . . . . . . . . . . . 470 x 40 mm (18.5 x 1.575 in)
Wheels and Tires
Lugs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Torque . . . . . . . . . . 461 to 488 Nm (340 - 360 lb-ft)
Tire Size
Standard . . . . . . . . . . . 33.25 x 29-38 ply rating
Optional . . . . . . . . . . . . . . . . . . . . . . . 29.5R29
NOTE: For roading and lifting pressures, refer to the Load
Chart Book in the cab.
Swing Gearbox
Reduction Ratio . . . . . . . . . . . . . . . . . . . . . . . . 36:2
Output Torque . . . . . . . . . . . . 5629 Nm (4152 lb-ft)
Boom
Length
Retracted . . . . . . . . . . . . . . . . . . 12.8 m (42 ft)
Extended. . . . . . . . . . . . . 48.5 m (159 ft 3.6 in)
Power. . . . . . . . . . . . . . . . . . . 5 Section, Full Power
Elevation . . . . . . . . . . . . . . . . . . .-3 to +78 degrees
Extensions
Fixed* . . . . . . . . . . . . . . . . . . 11 m (36 ft 1.2 in)
Folding*. . . . . . . . . . . . . . . . . . . . 11 m or 18 m
. . . . . . . . . . . . . . . . (36 ft 1.2 in or 59 ft 1.2 in)
*Extensions are offsettable at 0, 20, or 40
degrees.
Extension Insert . . . . . . . . . . . . . . .8 m (26 ft 2.4 in)
Swivel Assembly
Electrical . . . . . . . . . . . . . . . . . . . . . . 20 Slip Rings
Hydraulic . . . . . . . . . . . . . . . . . . . . . . . . . . 11 ports
Water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 ports