Pacific Power Source ADF Series - Page 4

ADF SERIES™ OPERATION MANUAL
CONTENTS
Entire Contents Copyright  2018 by Pacific Power Source, Inc. (PPS) • All Rights Reserved • No reproduction without written authorization from PPS.
ADF Series Power Source Operation Manual Page 4 of 349
5.12 Air Intake Filter Removal and Cleaning ........................................................................................................ 49
5.12.1 Air Filter Removal ............................................................................................................................................................... 50
5.12.2 Filter Cleaning ..................................................................................................................................................................... 50
5.12.3 Air Filter Installation ........................................................................................................................................................... 50
5.13 Liquids ............................................................................................................................................................ 50
5.14 Load Connections .......................................................................................................................................... 51
5.14.1 Output Wiring and Recommended Wire Sizing ............................................................................................................... 51
5.14.2 Three Phase Wye Load Output Connection – 3150ADF Only .......................................................................................... 52
5.14.3 Three Phase Delta Load Output Connection – 3150ADF Only......................................................................................... 55
5.14.4 Single Phase Load Output Connection – 1150ADF Only .................................................................................................. 58
5.14.5 External Voltage Sense Connections ................................................................................................................................. 60
5.14.6 Powering Up ....................................................................................................................................................................... 62
5.14.7 In Case of Malfunction ....................................................................................................................................................... 62
5.15 Cabinet Systems Installation ......................................................................................................................... 63
5.15.1 Standard Cabinet Sizes ....................................................................................................................................................... 63
5.15.2 Tools Required .................................................................................................................................................................... 63
5.15.3 Dimensions ......................................................................................................................................................................... 64
5.15.4 Cabinet System AC Input Connections .............................................................................................................................. 67
5.15.5 Recommended AC Input Wire Strip Lengths .................................................................................................................... 68
5.15.6 Cabinet System AC Input Neutral ...................................................................................................................................... 68
5.15.7 Cabinet System Grounding ................................................................................................................................................ 69
5.15.8 Recommended AC Output Wire Strip Lengths ................................................................................................................. 70
5.15.9 Cabinet Load Connections ................................................................................................................................................. 70
5.16 ADF Cabinet Systems Turn ON and turn OFF Procedures ........................................................................... 71
5.16.1 Cabinet Power Turn ON using Circuit Breakers ................................................................................................................ 71
5.16.2 Cabinet Power Turn OFF using Circuit Breakers ............................................................................................................... 71
5.17 Cabinet System Options ................................................................................................................................ 73
5.17.1 -OCS: Output Control Switch Option ................................................................................................................................. 73
5.18 Interface Options ........................................................................................................................................... 73
5.18.1 Rear Panel Connector Locations ........................................................................................................................................ 73
5.18.2 USB Device Interface .......................................................................................................................................................... 74
5.18.3 GPIB Device Interface ......................................................................................................................................................... 74
5.18.4 LAN Interface ...................................................................................................................................................................... 74
5.18.5 System Interface Bus Connectors ...................................................................................................................................... 76
5.19 Multi-Unit Parallel Operation ....................................................................................................................... 76
5.19.1 Load Connections on Parallel Systems .............................................................................................................................. 76
5.19.2 Parallel System Bus Connection ........................................................................................................................................ 77
5.19.3 Master / Master Paralleling ............................................................................................................................................... 78
5.20 MuIti-Cabinet Parallel Operation Guidelines ............................................................................................... 79
5.20.1 Output Wiring ..................................................................................................................................................................... 79
5.20.2 System Grounding .............................................................................................................................................................. 79
6 Front Panel Operation .................................................................................................................... 81
6.1 Front Panel Layout ........................................................................................................................................ 81
6.1.1 Keyboard Buttons ............................................................................................................................................................... 82
6.1.2 Shuttle Knob ....................................................................................................................................................................... 83
6.1.3 PC Monitor Output ............................................................................................................................................................. 83
6.1.4 USB Host Ports .................................................................................................................................................................... 83
6.1.5 SD Card Memory Slot ......................................................................................................................................................... 83
6.2 OUTPUT ENABLE Button ............................................................................................................................... 84
6.2.1 OUTPUT State Indication ................................................................................................................................................... 84
6.2.2 Energy Savings Modes........................................................................................................................................................ 84
6.2.3 Output On Response Times ............................................................................................................................................... 84
6.3 Menu Keys ..................................................................................................................................................... 85
6.4 PROG – PROGRAM & MEASUREMENTS Screen .......................................................................................... 86
6.4.1 Power On Settings .............................................................................................................................................................. 87