Panasonic MINAS A5 Series - Page 66

2-18
E-frame, 200 V type
:LULQJVKRXOGEHSHUIRUPHGE\DVSHFLDOLVWRUDQDXWKRUL]HGSHUVRQQHO
'RQRWWXUQRQWKHSRZHUXQWLOWKHZLULQJLVFRPSOHWHG
1HYHUWRXFKWKHSRZHUFRQQHFWRU;$;%DQG;&WRZKLFKKLJKYROWDJHLVDSSOLHG
There is a risk of electric shock.
 Tips on Wiring
1) Wire connector (XA, XB and XC).
2) Connect the wired connector to the driver.
Fully insert the connector to the bottom until it clicks.
Motor
Varistor
DC
24V
U
V
W
E
Fuse (125 V 10 A)
&KHFNWKHQDPHSODWHRIWKHGULYHUIRUSRZHU
VSHFLILFDWLRQV
3URYLGHDUHVLGXDOFXUUHQWGHYLFH7KHUHVLGXDOFXUUHQW
GHYLFHWREHWKHRQHGHVLJQHGIRU,QYHUWHUDQGLV
HTXLSSHGZLWKFRXQWHUPHDVXUHVIRUKDUPRQLFV
3URYLGHDFLUFXLWEUHDNHU
0DNHVXUHWRSURYLGHDQRLVHILOWHU
3URYLGHFRLOVXUJHVXSSUHVVLRQXQLWVWRWKHFRLORIWKH
0DJQHWLF&RQWDFWRUUHFRPPHQGHGE\PDQXIDFWXUHU
Never start/stop the motor with this Magnetic
Contactor.
3URYLGHDQ$&5HDFWRU
Connect L1 and L1C, and L3 and L2C at single
phase use (100V and 200V), and don't use L2.
'RQWGLVFRQQHFWWKHVKRUWLQJFDEOHEHWZHHQ%DQG%
'LVFRQQHFWWKLVRQO\ZKHQWKHH[WHUQDOUHJHQHUDWLYH
UHJLVWHULVXVHG
'RQRWFRQQHFWDQ\WKLQJWR1&
0DWFKWKHFRORUVRIWKHPRWRUOHDGZLUHVWRWKRVHRIWKH
FRUUHVSRQGLQJPRWRURXWSXWWHUPLQDOV89:
Avoid shorting and grounding. Don't connect the
main power.
Earth-ground this.
7RSUHYHQWHOHFWULFVKRFNEHVXUHWRFRQQHFWWKHJURXQG
WHUPLQDORIWKHGULYHUDQGWKHJURXQGWHUPLQDO
JURXQGSODWHRIWKHFRQWUROSDQHO
7KHJURXQGWHUPLQDOPXVWQRWEHVKDUHGZLWKRWKHU
HTXLSPHQW
 7ZRJURXQGWHUPLQDOVDUHSURYLGHG
Don't connect the earth cable to other inserting slot,
nor make them touch.
&RPSRVHDGXSOH[%UDNH&RQWURO&LUFXLWVRWKDWWKH
EUDNHFDQDOVREHDFWLYDWHGE\DQH[WHUQDOLPPHGLDWH
VWRSVLJQDO
7KHKROGLQJEUDNHKDVQRSRODULWLHV
)RUWKHKROGLQJEUDNHSRZHUVXSSO\FDSDFLW\DQGKRZWR
XVHWKHEUDNHUHIHUWR´6SHFLILFDWLRQVRI%XLOWLQ+ROGLQJ
%UDNHµRQ3
3URYLGHDYDULVWRU
 &RQQHFWD$IXVHLQVHULHVZLWKWKHYDULVWRU
*URXQGUHVLVWDQFHїPD[
)RUDSSOLFDEOHZLUHUHIHUWR3
L1C
/
L2
L1
L2C
%
%
1&
U
V
W
XA
XC
;%
2
3
4
5
1
2
3
1
3
%
2
4
1
'&SRZHUVXSSO\
IRUEUDNH
5HG
%ODFN
*UHHQ
:KLWH
0&&%
3RZHU
VXSSO\
1) MC L5&'
([WHUQDOUHJHQHUDWLYH
resistor
7KHVHFRORUV
 DUHXVHGIRU
 RSWLRQDOFDEOH
2
Preparation
2. 6\VWHP&RQÀJXUDWLRQDQG:LULQJ
Wiring of the Main Circuit (E-frame, 200 V type)
Note
Related page
The wiring indicated with the broken line shall be provided only when required.
3´6SHFLÀFDWLRQVRI0RWRUFRQQHFWRUµ3´:LULQJPHWKRGWRFRQQHFWRUµ
3´&RQQHFWRUNLWIRU;$µ3´&RQQHFWRUNLWIRU;%;&µ
Phone: 800.894.0412 - Fax: 888.723.4773 - Web: www.clrwtr.com - Email: info@clrwtr.com