To Next Page

To Previous Page

Table of Contents 6- i

Section 6

CONTENTS

Steering

Precautions .................................................6-1

Precautions............................................................. 6-1

Precautions for Steering ....................................... 6-1

Steering General Diagnosis.................... 6A-1

Diagnostic Information and Procedures............6A-1

Steering Symptom Diagnosis..............................6A-1

Steering Wheel and Column................... 6B-1

Precautions...........................................................6B-1

Service Precautions of Air Bag Steering

Wheel and Column ...........................................6B-1

Handling and Storage of Air Bag Steering

Wheel and Column ...........................................6B-1

Disposal of Air Bag Steering Wheel and

Column..............................................................6B-1

General Description .............................................6B-1

Steering Wheel and Column Construction ..........6B-1

Diagnostic Information and Procedures............6B-3

Air Bag Steering Wheel and Column

Symptom Diagnosis .......................................... 6B-3

Air Bag Steering Wheel and Column

Inspection and Repair Required after

Accident ............................................................6B-3

Diagnosis and Servicing of Air Bag Steering

Wheel and Column ...........................................6B-3

Repair Instructions ..............................................6B-3

Checking Steering Column for Accident

Damage ............................................................6B-3

Steering Wheel Removal and Installation ...........6B-4

Contact Coil Cable Assembly Removal

and Installation.................................................. 6B-5

Contact Coil Cable Assembly Inspection ............ 6B-7

Centering Contact Coil Cable Assembly ............. 6B-7

Steering Column Assembly Removal and

Installation.........................................................6B-7

Steering Column Assembly Inspection .............6B-10

Ignition Switch Cylinder Assembly

Removal and Installation (Without Keyless

Start System) .................................................. 6B-10

Steering Lock Assembly (Ignition Switch)

Removal and Installation................................. 6B-11

Adjustable Steering Column Release

Lever Inspection..............................................6B-11

Steering Upper Shaft Assembly Removal

and Installation................................................ 6B-11

Steering Upper Shaft Assembly Inspection....... 6B-12

Steering Lower Shaft Assembly Removal

and Installation ................................................6B-13

Specifications.....................................................6B-14

Tightening Torque Specifications......................6B-14

Special Tools and Equipment ...........................6B-14

Special Tool ......................................................6B-14

Power Assisted Steering System........... 6C-1

Precautions...........................................................6C-1

P/S System Note.................................................6C-1

General Description .............................................6C-1

P/S System Construction ....................................6C-1

Steering Gear Case Construction .......................6C-2

P/S Pump Construction.......................................6C-2

Schematic and Routing Diagram........................6C-3

P/S Fluid Flow Diagram ......................................6C-3

Diagnostic Information and Procedures............6C-3

P/S System Symptom Diagnosis ........................6C-3

Steering Wheel Check ........................................6C-4

Steering Force Check .........................................6C-5

Steering Wheel Recovery Check ........................6C-5

Idle Up System Check.........................................6C-5

Hydraulic Pressure in P/S Circuit Check.............6C-5

Repair Instructions ..............................................6C-7

P/S Fluid Change ................................................6C-7

P/S Fluid Level Check.........................................6C-7

P/S Fluid Leakage Check....................................6C-8

P/S System Air Bleeding Procedure ...................6C-8

P/S Pump and A/C Compressor (If

Equipped) Drive Belt Inspection and

Adjustment for M16 Engine Model ....................6C-9

P/S Pump and A/C Compressor (If

Equipped) Drive Belt Inspection and

Adjustment for J20 Engine Model .....................6C-9

P/S Pump and A/C Compressor (If

Equipped) Drive Belt Removal and

Installation for M16 Engine Model.....................6C-9

P/S Pump and A/C Compressor (If

Equipped) Drive Belt Removal and

Installation for J20 Engine Model ....................6C-10

Steering Rack Boot Check ................................6C-10

Tie-Rod End Boot Check ..................................6C-10

Tie-Rod End Removal and Installation..............6C-10

Tie-Rod End Ball Joint Inspection .....................6C-11

P/S Gear Case Assembly Components ............6C-12

P/S Gear Case Assembly Removal and

Installation .......................................................6C-13

Brand	Suzuki
Model	Grand Vitara 2005
Category	Automobile
Language	English

Suzuki Grand Vitara 2005 Owner's Manual

Table of Contents

Other manuals for Suzuki Grand Vitara 2005

Questions and Answers:

Suzuki Grand Vitara 2005 Specifications

Related product manuals