TROUBLESHOOTING
11-6
ELECTRICAL SYSTEM
Problem Cause Solution
Engine Cranks Slowly
Battery discharged or will not hold a
charge
Replace battery.
Starter “dragging” See your authorized dealer.
Low battery voltage Recharge or replace battery.
Start relay stuck See your authorized dealer.
Starter Motor Continues to
Run After Engine Starts
Starter solenoid stuck See your authorized dealer.
Starter not disengaging See your authorized dealer.
Key switch See your authorized dealer.
Charging Indicator Light
On-Engine Running
Loose or glazed alternator belt Check belt.
Replace if glazed, tighten if loose.
Engine rpm low Adjust rpm to specification.
Excessive electrical load from added
accessories
Remove accessories or install higher
output alternator.
Loose or corroded electrical
connections on battery, ground strap,
starter, or alternator
Inspect, clean, or tighten electrical
connections.
Battery voltage low Change or replace battery.
Alternator or regulator See your authorized dealer.
Indicator circuit See your authorized dealer.
Noisy Alternator
Worn drive belt Replace belt.
Worn pulleys Replace pulleys and belt.
Pulley misaligned Adjust alternator mount.
Alternator bearing Loosen alternator belts.
Turn pulley by hand.
If any roughness is felt, repair
alternator.
Fuse Replace fuse.
No Monitor Panel Indicators
Work
Wiring harness See your authorized dealer.
Bulb Replace bulb.
Individual Light in Monitor
Panel is Not Working
Fuse Replace fuse.
Wiring harness See your authorized dealer.
To Next Page
Loading...
