Section 2 - Care and Safety
Safety Notices
Safety Checklist
2-11 2-11
9803/9340-8
!M
WARNING
Counterweights
Your machine may be fitted with counterweights. They
are extremely heavy. Do not attempt to remove them.
INT-3-2-5
!M
WARNING
Turning the Engine
Do not try to turn the engine by pulling the fan or fan
belt. This could cause injury or premature component
failure.
0094
!M
WARNING
Accumulators
The accumulators contain hydraulic fluid and gas at
high pressure. Prior to any work being carried out on
systems incorporating accumulators, the system
pressure must be exhausted by a JCB distributor, as
the sudden release of the hydraulic fluid or gas may
cause injury.
INT-3-1-17
!M
WARNING
Compressed air is dangerous. Wear suitable eye
protection and gloves. Never point a compressed air
jet at yourself or others.
0147_1
!M
CAUTION
Do not switch the battery isolator OFF while the engine
is running. Failure to comply may result in damage to
the electrical circuits.
4-2-1-7
!M
WARNING
Non approved modifications to drive ratios, machine
weight or wheel and tyre sizes may adversely affect
the performance of the parking brake.
3-2-3-11
!M
WARNING
Asbestos
Asbestos dust can damage your lungs. Some engine
gaskets contain asbestos. Do not dismantle the
engine or exhaust system; get these jobs done by a
qualified person who has a copy of the engine service
manual.
5-1-6-1
!M
WARNING
An exploding tyre can kill. Inflated tyres can explode if
over-heated or over-inflated. Follow the instructions
given when inflating the tyres. Do not cut or weld the
rims. Use a tyre/wheel specialist for all repair work.
2-3-2-7_2
!M
WARNING
Jacking
A machine can roll off jacks and crush you unless the
wheels have been blocked. Always block the wheels at
the opposite end of the machine that is to be jacked.
Do not work underneath a machine supported only by
jacks. Always support a jacked-up machine on axle
stands before working underneath it.
INT-3-2-8
!M
WARNING
Under no circumstances must the engine be run with
the transmission in gear and only one driving wheel
jacked clear of the ground, since the wheel on the
ground will move the machine.
INT-3-1-16
!M
WARNING
Wheels and tyres are heavy. Take care when lifting or
moving them.
Store with care to ensure that they cannot fall and
cause injury.
13-3-1-7_1
To Next Page
Loading...
