JETStream X Series - Appendix B: Long Term Storage Procedure

X-Series Waterblast Unit
INDEX-1
INDEX
A
APPENDIX A: TECHNICAL SPECIFICATIONS A-1
General Unit Information A-1
APPENDIX B: LONG TERM STORAGE B-1
C
COMPONENT IDENTIFICATION 7, 19
Batteries 11
Belt Drive 7
Bypass Drain 10
Bypass Valve 9
Charge Pump (40K Units) 12
Clutch and PTO 7
Control Panel 10
Discharge Fitting 10
Engine 7
Fluid End and Unit Identication 12
Fuel Tank 11
Hydro-Throttle Switch 8
Manifold 8
Manifold Drain Valve 8
Pressure Gauge 8
Regulator Valve 9
Rupture Discs 9
Secondary Filter (40K Units) 11
Supply Couplings 10
Supply Inlet 10
UNx Pump 7
Water Lubrication System 8
Water Tank and Filters 7
Water Tank Drain Valve 10
CONTROL PANEL 17
Jetstream Connections 18
Keyswitch Operation 18
J
Jetstream 5200
Bareshaft Pump Installation
Guidelines 21
M
MAINTENANCE 33
Trailer Breakaway System 37
System Check 37
Trailer Maintenance 36
Axles 36
Lug Nuts 36
Tires 36
Wheel Bearings 36
Unit Maintenance 33
50 Hours 33
100 Hours 33
500 Hours 33
Winterizing the Unit 34
O
OPERATION 23
Breaking in New Packing 29
Checking The Water Lubrication System 27
Flushing The System 26
Hose and Water Supply Requirements 24
Monitoring Weep Holes 30
Preparing the Unit 23
Raising System Pressure 28
Recommended Equipment 24
Starting the Unit 25
Start-up Preparation 24
Stopping the Unit 31
Using the Hydro-Throttle (Dump System Only) 29
P
PRESSURE CONVERSION 43
40K Hose Connections 50
Converting a Pump 43
Manifold Trunnion Adjustment 47
S
SERVICE 51
Fluid End 51
15K, 20K Uni-Valve Service 61
Assembly 64
Disassembly 61
40K Face Seal Replacement 59
Installation 60
40K Uni-Valve Service 65
Assembly 67
Disassembly 65
Valve Inspection 68
Valve Lapping 68
Bypass Valve Cartridge Replacement 69
Checking Gland Nut Torque 51
Checking Manifold Bolt Torque 51