Jonker Sailplanes JS3 RES - Page 9

JS-MD 3 RES Maintenance Manual
Supplement
MD11-AMM-00-002
Issue: 00
Rev. 00
Rev. Date: 23-May-22
Page 0–5
Fire warning system ........................................................................................... 4-79
5 Calibration & setup ................................................................................................... 5-1
Actuator system setup .......................................................................................... 5-1
Actuator calibration ............................................................................................... 5-4
Main door setup.................................................................................................... 5-4
Motor resolver calibration ..................................................................................... 5-5
Propeller alignment .............................................................................................. 5-6
6 Wiring loom ............................................................................................................... 6-1
Display And Control Unit (DCU) ........................................................................... 6-1
RES Control Board (RCB) .................................................................................... 6-2
Retraction And Fuses Unit (RFU) ......................................................................... 6-4
Actuator ................................................................................................................ 6-5
Left battery connector ........................................................................................... 6-6
Charger connector ................................................................................................ 6-7
DC-DC converter .................................................................................................. 6-8
Right battery connector ........................................................................................ 6-9
Motor, motor controller and resolvers ................................................................. 6-10
Cooling fans ....................................................................................................... 6-11
Insulation Monitoring Device (IMD) ..................................................................... 6-12
Avionic batteries ................................................................................................. 6-13
Ground bus ........................................................................................................ 6-14
Supplementary fire warning system .................................................................... 6-15
LXNAV bridge .................................................................................................... 6-16
Complete schematic ........................................................................................... 6-17
Supplementary information and pictures ............................................................ 6-18
7 Lubrication ................................................................................................................ 7-1
Introduction .......................................................................................................... 7-1
Lubricants............................................................................................................. 7-1
Lubrication plan .................................................................................................... 7-1
8 System operation ...................................................................................................... 8-1
Guarded RES master switch ................................................................................ 8-1
Display and control unit interface .......................................................................... 8-2
Battery selection switch ........................................................................................ 8-2
Operational mode ................................................................................................. 8-3
Other Information screens .................................................................................... 8-8
Warning Caution and Information messages ...................................................... 8-10