M0312-01Model 3605
ii 07/20
Table of Contents
FERTILIZER
Double Disc Fertilizer Opener ......................4-1
Notched Single Disc Opener . . . . . . . . . . . . . . . . . . . . . . . 4-2
Residue Wheel Attachment for Notched
Single Disc Fertilizer Opener . . . . . . . . . . . . . . . . . . . . . . . 4-4
Depth/Gauge Wheel Attachment for Notched
Single Disc Fertilizer Opener ......................4-4
HD Single Disc Fertilizer Opener ....................4-5
Dry Fertilizer Attachment . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7
Liquid Fertilizer Attachment ........................4-9
RATE CHARTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
LUBRICATION AND MAINTENANCE
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-1
Lubrication Symbols .............................6-1
Sealed Bearings ................................6-1
Wrap Spring Wrench Assembly . . . . . . . . . . . . . . . . . . . . . 6-1
Drive Chains ...................................6-2
Bushings ......................................6-3
Center Post ....................................6-5
U-Joint Slides. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
PTO Pump Shaft Coupling (Tractor Mounted PTO Pump
and Oil Cooler) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-5
Wheel Bearings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6
Liquid Fertilizer Piston Pump ......................6-6
Crankcase Oil Level. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-6
Grease Fittings .................................6-6
Mounting Bolts and Hardware .....................6-10
Tire Servicing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-12
Finger Pickup Seed Meter Inspection/Adjustment. . . . . . 6-13
Cleaning Finger Pickup Seed Meter For Storage ......6-14
Brush-Type Seed Meter Maintenance ...............6-15
Cleaning Brush-Type Seed Meter For Storage ........6-16
Vacuum Seed Meter Maintenance. . . . . . . . . . . . . . . . . . 6-17
Seed Meter Cleanout. . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-17
Chain Tension Adjustment . . . . . . . . . . . . . . . . . . . . . . . . 6-18
Drag Closing Attachment ........................6-18
Gauge Wheel Adjustment ........................6-18
Gauge Wheel Arm Bushing/Seal Replacement . . . . . . . . 6-19
Gauge Wheel Arm Pivot Spindle Replacement . . . . . . . . 6-20
15" Seed Opener Disc Blade/Bearing Assembly .......6-21
Seed Tube Guard/Inner Scraper ...................6-23
Row Unit Mounted Disc Furrower ..................6-24
Row Unit Mounted No Till Coulter ..................6-24
Coulter Mounted Residue Wheels . . . . . . . . . . . . . . . . . . 6-25
Row Unit Mounted Residue Wheel .................6-25
Granular Chemical Attachment ....................6-25
Point Row Clutch Maintenance ....................6-26
Check Valve (Lift System) ........................6-28
Check Valve (Vacuum Fan) .......................6-28
Flow Control Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-28
Pressure Relief Valve. . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-28
Pressure Reducing Relief Valve. . . . . . . . . . . . . . . . . . . . 6-28
Relief Valve Cartridge ...........................6-28
Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-29
Row Marker Bearing Lubrication or Replacement . . . . . . 6-30
Row Marker Transport Stand Adjustment ............6-31
Wheel Bearing Repack or Replacement .............6-31
Wear Pad Field Replacement/Adjustment . . . . . . . . . . . . 6-32
Tractor Mounted PTO Pump and Oil Cooler Option. . . . . 6-36
Pneumatic Down Pressure Air Compressor Tank ......6-36
Fertilizer Check Valve Cleaning and Repair ...........6-38
Piston Pump Storage. . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-38
Electrical Control Console Schematic ...............6-39
Valve Block - Located on Hitch ....................6-40
Valve Block - Located on Rear Center Frame .........6-41
Hydraulic Hose Life .............................6-42
Hydraulic System Schematic . . . . . . . . . . . . . . . . . . . . . . 6-43
Hydraulic Schematic - Vacuum Fan Motor System .....6-46
Hydraulic Schematic - Optional Tractor Driven
PTO Pump and Oil Cooler System .................6-46
Wing Down Pressure Schematic
(Weight Transfer Mechanism) .....................6-47
Electrical Control Console Connections - isobus .......6-48
Power Pack Wiring Diagram (Blue Drive). . . . . . . . . . . . . 6-50
Cables and Harnesses ..........................6-51
TROUBLESHOOTING ......................7-1
Bulk Fill .......................................7-1
Closing Wheel ..................................7-1
Lift Circuit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
PTO Pump Drive and Oil Cooler Option ..............7-3
Point Row Clutch ................................7-3
Rotation Circuit .................................7-4
Row Marker Operation ............................7-4
Seed Meter (Brush-Type). . . . . . . . . . . . . . . . . . . . . . . . . . 7-5
Seed Meter (Vacuum) ............................7-6
Seed Meter (Finger Pickup) .......................7-8
Solenoid Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-8
Tongue Cylinder Circuit ...........................7-9
Wing Lock Cylinder Circuit. . . . . . . . . . . . . . . . . . . . . . . . . 7-9
To Next Page
Loading...
