LeeBoy 8510b - Page 18

2-4 LeeBoy Model 8510B Conveyor Paver
Safety
The safety messages that follow have WARNING
level hazards.
Exhaust Hazard
All internal combustion engines create
carbon monoxide gas during operation and
special precautions are required to avoid
carbon monoxide poisoning:
• Always ensure that all connections are tightened to
specications after repair is made to the exhaust
system.
Entanglement/Sever Hazard
Verify there are no people, obstacles or other
equipment near the LeeBoy Model 8510B Conveyor
Paver before starting the engine. Sound the horn as a
warning before starting the engine.
If the engine must be serviced while it is
operating, remove all jewelry, tie back long
hair and keep hands, other body parts and
clothing away from moving/rotating parts.
• Always stop the engine before
beginning service.
• Verify that all paver guards and covers
are attached properly to the paver before
starting the engine.
• If you must run the engine during maintenance
procedures, make sure you have a helper to keep
bystanders clear of the paver and make observations
of moving parts as requested by the operator.
• Always turn the start switch to the OFF position after
operation is complete and remove the key from the
switch. Keep the key in your possession when the
paver is not operating.
• Attach a “Do Not Operate” tag near the key switch
while performing maintenance on the equipment.
• Never operate the engine while wearing a headset to
listen to music or radio because it will be difcult to
hear the warning signals.
• Always start the engine or operate the controls while
you are seated in the operators seat.
Alcohol and Drug Hazard
Never operate the engine or 8510B Paver
while under the inuence of alcohol or
drugs, or when ill.
Piercing Hazard
Avoid skin contact with high-pressure hydraulic uid or
diesel fuel spray caused by a hydraulic or fuel system
leak such as a broken hydraulic hose or fuel injection
line. High-pressure hydraulic uid or fuel
can penetrate your skin and result in
serious injury. If you are exposed to high-
pressure hydraulic uid or fuel spray, obtain
prompt medical treatment.
• Never check for a hydraulic uid or fuel leak with your
hands. Always use a piece of wood or cardboard.
Have your authorized LeeBoy Dealer or distributor
repair the damage.
Flying Object Hazard
Always wear eye protection when cleaning
the LeeBoy Model 8510B Conveyor Paver
with compressed air or high-pressure
water. Dust, ying debris, compressed air,
pressurized water or steam may injure your
eyes.
Coolant Hazard
Wear eye protection and rubber gloves
when handling engine coolant. If contact
with the eyes or skin should occur, ush
eyes and wash immediately with clean
water.
Burn Hazard
Some of the paver surfaces become very
hot during operation and shortly after
shutdown.
• Keep hands and other body parts away
from hot paver surfaces.
• Handle hot components with heat-resistant gloves.
Return to
Last Viewed
Return to
Thumb Index