LeeBoy 8515D - User Manual

Questions and Answers

F
Frank SotoAug 19, 2025
Why is the electric screed heating system not working on my LeeBoy 8515D?
- J
  Jose FoxAug 20, 2025
  If the electric screed heating system on your LeeBoy Accessories isn't working, check the following: * **Control box power switch:** Ensure the screed operator control box power switch is in the ON position. * **Breakers:** Make sure all element breakers are in the proper set position (not tripped). * **Generator:** Ensure the generator is spinning and check its voltage and frequency. Rebuild or replace the generator if needed.
N
nhoffmanAug 21, 2025
Why don't the tracks on my LeeBoy Accessories operate smoothly?
- S
  Shelby LeeAug 22, 2025
  If the tracks on your LeeBoy Accessories aren't operating smoothly, consider these potential issues: * **Loose tracks:** Tighten the track pad bolts. * **Low engine RPM:** Rev the engine to 1400 RPMs, then throttle back to 700 RPMs. * **Worn track rollers:** Replace the track rollers. * **Track tension pressure:** Check the tension pressure and relieve or adjust it.
W
wesleyfreemanAug 25, 2025
What to do if the LeeBoy Accessories engine runs but has no hydraulic pressure?
- D
  Daniel RobertsAug 25, 2025
  If the engine of your LeeBoy Accessories runs but there's no hydraulic pressure, it could be due to: * **Faulty pump drive coupling:** Replace the coupling. * **Defective pump:** Replace the pump.
D
David GayAug 26, 2025
Why is hydraulic oil leaking from the breather cap on my LeeBoy 8515D?
- J
  Jeffrey ForbesAug 26, 2025
  If hydraulic oil is leaking from the breather cap on your LeeBoy Accessories, it could be because: * **Overfilled hydraulic oil tank:** Drain the tank to the proper fill level. * **Overheated oil:** Slow the paver down. * **Oil cooler and thermostat:** Check oil cooler and thermostat.
M
Michael CardenasAug 27, 2025
What causes screed extensions binding on LeeBoy 8515D?
- C
  Charles NorrisAug 27, 2025
  If the screed extensions are binding on your LeeBoy Accessories, it's likely due to asphalt buildup. Keep them clean and greased.
K
Kayla NelsonAug 29, 2025
How to fix a LeeBoy Accessories engine that won't start?
- D
  Daniel LongAug 29, 2025
  If your LeeBoy Accessories engine won't start, there are several potential causes and solutions: * **Defective or low battery:** Replace or charge the battery. * **Master switch not ON:** Set the master switch to the ON position. * **Insufficient fuel:** Fill the fuel tank. * **Faulty safety switch:** Replace the safety switch. * **Solenoid issues:** Ensure wires are tight, clean the solenoid plunger, and replace the solenoid coil. If needed, replace or rebuild the starter or solenoid. * **Unplugged switch box:** Replug the switch box. * **Defective neutral switch:** Replace the neutral switch. * **Faulty engine starter relay:** Replace the relay. * **E-Stop engaged:** Disengage the E-Stop.
B
Brandon CastilloAug 31, 2025
What to do if my LeeBoy 8515D engine turns over but won't start?
- B
  Bobby AndersonSep 1, 2025
  If your LeeBoy Accessories engine turns over but fails to start, consider these possibilities: * **Low fuel:** Add fuel to the fuel tank. * **Low battery:** Replace or rebuild the battery. * **Indicator light issue:** Replace the bulb if it's bad.
W
williamsandrewSep 2, 2025
Why won't my LeeBoy Accessories machine move?
- J
  Jeremy CastroSep 2, 2025
  If your LeeBoy Accessories machine won't move, the RUN/STOP switch might be faulty. Check the RUN/STOP switch.
B
brandythompsonSep 4, 2025
Why isn't my LeeBoy Accessories electric screed getting hot enough to pave?
- S
  Sarah KennedySep 4, 2025
  If your LeeBoy Accessories electric screed is heating but not reaching paving temperature, consider these factors: * **Elements improperly clamped:** Ensure the elements are clamped properly. * **Generator malfunction:** Ensure the generator is spinning and check its voltage and frequency. Rebuild or replace if needed.
J
Jessica LewisSep 6, 2025
How do I fix a LeeBoy 8515D Accessories machine that doesn't steer straight?
- S
  Steven ZamoraSep 6, 2025
  If your LeeBoy Accessories machine isn't steering straight, here are some possible causes: * **Hydraulic drive motor adjustment:** One of the hydraulic drive motors may need readjustment. * **Steering control:** The steering control might not be centered; ensure it is. * **Travel pump:** The travel pump could be defective; consider replacing or rebuilding it.