Manitowoc Grove RT9130E-2 User Manual

Grove Published 3-1-2018, Control # 559-03 3-3
RT9130E-2 OPERATOR MANUAL OPERATING CONTROLS AND PROCEDURES
3
Stowing the Mid-Extend Lock Pin . . . . . . . . . . . . 3-42
Swinging the Boom . . . . . . . . . . . . . . . . . . . . . . . 3-42
Elevating and Lowering the Boom . . . . . . . . . . . 3-43
Telescoping the Boom . . . . . . . . . . . . . . . . . . . . 3-43
Lowering and Raising the Hoist Cable . . . . . . . . 3-44
Raising and Lowering the Hydraulic Jib . . . . . . . 3-44
Operational Aids . . . . . . . . . . . . . . . . . . . . . . . . . . 3-45
Rated Capacity Limiter (RCL) System. . . . . . . . . 3-45
Control Lever Lockout System. . . . . . . . . . . . . . . 3-46
Stowing and Parking . . . . . . . . . . . . . . . . . . . . . . . 3-46
Unattended Crane . . . . . . . . . . . . . . . . . . . . . . . . 3-47
SECTION CONTENTS
Controls and Indicators . . . . . . . . . . . . . . . . . . . . . 3-3
Steering column . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-3
Drive Axle Selector Switch . . . . . . . . . . . . . . . . . . 3-3
Turn Signal Lever and Windshield Wiper/
Washer/Headlight /Horn Controls . . . . . . . . . . . . . 3-3
Steering Column Tilt/Telescope Lever . . . . . . . . . 3-4
Park Brake Control Switch . . . . . . . . . . . . . . . . . . 3-4
Headlights Switch . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
Drive Axle Selector Switch . . . . . . . . . . . . . . . . . . 3-4
Hazard Lights Switch . . . . . . . . . . . . . . . . . . . . . . 3-4
Engine Diagnostic and Engine Speed
Control Switches . . . . . . . . . . . . . . . . . . . . . . . . . . 3-4
Ignition Switch. . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-5
Transmission Shift Lever . . . . . . . . . . . . . . . . . . . 3-5
Cab Overhead Controls . . . . . . . . . . . . . . . . . . . . . 3-5
Skylight Window Latch . . . . . . . . . . . . . . . . . . . . . 3-5
Skylight Wiper and Wiper Motor . . . . . . . . . . . . . . 3-5
Skylight Sunscreen . . . . . . . . . . . . . . . . . . . . . . . . 3-6
Overhead Light . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-6
Cab Circulating Fan . . . . . . . . . . . . . . . . . . . . . . . 3-6
Right Side Window Latch . . . . . . . . . . . . . . . . . . . 3-6
Overhead Control Panel . . . . . . . . . . . . . . . . . . . . . 3-6
Heater/Air Conditioner Fan Switch . . . . . . . . . . . . 3-7
Heater Control Switch . . . . . . . . . . . . . . . . . . . . . . 3-7
Air Conditioner Switch. . . . . . . . . . . . . . . . . . . . . . 3-7
Skylight Wiper Switch . . . . . . . . . . . . . . . . . . . . . . 3-7
Dimmer Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-7
Work Lights Switch . . . . . . . . . . . . . . . . . . . . . . . . 3-7
Boom Lights Switch (Optional) . . . . . . . . . . . . . . . 3-7
Crane Function Power Switch. . . . . . . . . . . . . . . . 3-7
Hoist Rotation Indicator Display . . . . . . . . . . . . . . 3-7
Exhaust System Cleaning Switch
(Tier 4 Engines Only) . . . . . . . . . . . . . . . . . . . . . . 3-7
Boom Tele-1 / Tele-2 Select Switch & Indicator . . 3-8
Boom Manual/Auto Switch . . . . . . . . . . . . . . . . . . 3-8
Steering Column Indicator and Gauge Display . . 3-9
Swing Brake Engaged . . . . . . . . . . . . . . . . . . . . 3-10
Parking Brake Engaged . . . . . . . . . . . . . . . . . . . 3-10
Light Malfunction . . . . . . . . . . . . . . . . . . . . . . . . . 3-10
Emergency Stop . . . . . . . . . . . . . . . . . . . . . . . . . 3-10
Hydraulic Oil High Temperature . . . . . . . . . . . . . 3-10
Transmission Warning . . . . . . . . . . . . . . . . . . . . . 3-10
Low Steer Pressure . . . . . . . . . . . . . . . . . . . . . . . 3-10
Left Turn Signal Indicator. . . . . . . . . . . . . . . . . . . 3-10
Low Brake Pressure . . . . . . . . . . . . . . . . . . . . . . 3-10
Electronic Module Control . . . . . . . . . . . . . . . . . . 3-10
Electronic System Diagnostic . . . . . . . . . . . . . . . 3-10
LCD Display. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-11
Engine Stop . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-11
Engine Warning . . . . . . . . . . . . . . . . . . . . . . . . . . 3-11
Exhaust System Cleaning
(Tier 4 Engines Only). . . . . . . . . . . . . . . . . . . . . . 3-11
Right Turn Signal Indicator . . . . . . . . . . . . . . . . . 3-12
Inhibit Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Diesel Exhaust Fluid (Tier 4F Engines Only). . . . 3-12
High Exhaust System Temperature. . . . . . . . . . . 3-12
Engine Wait to Start. . . . . . . . . . . . . . . . . . . . . . . 3-12
Four-Wheel Drive Engaged . . . . . . . . . . . . . . . . . 3-12
Interaxle Locked . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Rear Wheels Not Centered Indicator. . . . . . . . . . 3-12
Engine Coolant Temperature Gauge. . . . . . . . . . 3-12
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Low Fuel Level. . . . . . . . . . . . . . . . . . . . . . . . . . . 3-12
Battery Charge Indicator . . . . . . . . . . . . . . . . . . . 3-13
Voltmeter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13
Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-13
Control Seat Assembly - Single Axis. . . . . . . . . . 3-14
Main Hoist Control (Single Axis Option) . . . . . . . 3-14
Boom Lift Control (Single Axis Option) . . . . . . . . 3-14
Boom Lift and Main Hoist Control Lever
(Dual Axis Option — Not Shown) . . . . . . . . . . . . 3-14
Main Hoist Speed Selector Switch. . . . . . . . . . . . 3-14
Auxiliary Hoist Control (Single Axis Option). . . . . 3-15
Swing Control (Single Axis Option) . . . . . . . . . . . 3-15
Swing and Telescope or Swing and
Auxiliary Hoist Control Lever

Manitowoc Grove RT9130E-2 Specifications

General

Brand	Manitowoc
Model	Grove RT9130E-2
Category	Construction Equipment
Language	English