Panasonic MINAS A5 Series - Page 277

4-61
1
Before Using the Products
2
Preparation
3
Connection
4
Setup
5
Adjustment
6
When in Trouble
7
Supplement
Trial Run (JOG run) at Velocity Control Mode
&RQQHFWWKH&RQQHFWRU;
(QWHUWKHSRZHU'&WR9WRFRQWUROVLJQDO&20&20²
(QWHUWKHSRZHUWRWKHGULYHU
&RQÀUPWKHGHIDXOWYDOXHVRISDUDPHWHUV
&RQQHFWWKH6HUYR21LQSXW65921&RQQHFWRU;3LQDQG&20²&RQQHFWRU
;3LQWRWXUQWR6HUYR21DQGHQHUJL]HWKHPRWRU
&ORVHWKHVSHHG]HURFODPSLQSXW=(5263'DQGDSSO\'&YROWDJHEHWZHHQYHORFLW\
FRPPDQGLQSXW635&RQQHFWRU;3LQDQG*1'&RQQHFWRU;3LQDQG
JUDGXDOO\LQFUHDVHIURP9WRFRQÀUPWKHPRWRUUXQV
&RQÀUPWKHPRWRUURWDWLRQDOVSHHGLQPRQLWRUPRGH
 :KHWKHUWKHURWDWLRQDOVSHHGLVSHUWKHVHWXSRUQRW
 :KHWKHUWKHPRWRUVWRSVZLWK]HURFRPPDQGRUQRW
,IWKHPRWRUGRHVURWDWHDWDPLFURVSHHGZLWKFRPPDQGYROWDJHRI
:KHQ\RXZDQWWRFKDQJHWKHURWDWLRQDOVSHHGDQGGLUHFWLRQVHWXSWKHIROORZLQJSD-
rameters again.
 3U6SHHGVHWXS,QWHUQDO([WHUQDOVZLWFKLQJ
 3U6SHHGFRPPDQGURWDWLRQDOGLUHFWLRQVHOHFWLRQ
 3U5HYHUVDORIVSHHGFRPPDQGLQSXW
,IWKHPRWRUGRHVQRWUXQFRUUHFWO\UHIHUWR3'LVSOD\RI)DFWRUIRU1R0RWRU
5XQQLQJRI3UHSDUDWLRQ
:LULQJ'LDJUDP
3DUDPHWHU
Pr No. Title Setup value
0.01 Control mode setup 1
5.04 2YHUWUDYHOLQKLELWLQSXWVHWXS 1
3.15 Speed zero-clamp function selection 1
3.00 6SHHGVHWXS,QWHUQDO([WHUQDOVZLWFKLQJ
Set up as
required
3.01 Speed command rotational direction selection
3.02 Input gain of speed command
3.03 5HYHUVDORIVSHHGFRPPDQGLQSXW
4.22 $QDORJLQSXW$,RIIVHWVHWXS
4.23 $QDORJLQSXW$,ILOWHU
,QSXWVLJQDOVWDWXV
No. Title of signal Monitor display
0 6HUYR21 $
5 Speed zero clamp —
COM+
SRV-ON
SPR/TRQR/SPL
GND
ZEROSPD
COMï
7
29
14
15
26
41
DC
12V to 24V
Run with ZEROSPD switch close,
and Stop with open
In case of one-directional operation
DC
10V
In case of bi-directional operation
(Positive/Negative), provide a bipolar
power supply, or use with Pr3.15 = 3.
5HIHUWR33DUDP-
HWHU6HWXS3DUDPHWHUVIRU
9HORFLW\7RUTXH&RQWURO
2.Trial Run (JOG run)
Trial Run by Connecting the Connector X4
Note
2QO\IRUSRVLWLRQFRQWUROW\SHLVQRWSURYLGHGZLWKDQDORJLQSXW
Phone: 800.894.0412 - Fax: 888.723.4773 - Web: www.clrwtr.com - Email: info@clrwtr.com