PoolPak MPK series - Page 6

www.poolpak.com | 800-959-77256 | MPK Series - Installation, Operation and Maintenance
Figure 2-1. Dewpoint Control Psychrometric .................................................................................................. 12
Figure 2-2. MPK System Schematic .............................................................................................................. 14
Figure 2-3. Active Airflow Control with Direct OA Measurement Schematic ...................................................... 16
Figure 3-1. MPK Dimensional Isometric View .................................................................................................22
Figure 3-2. Remote Cooling Tower Dimensions .............................................................................................. 25
Figure 4-1. Typical PoolPak Rooftop Installation .............................................................................................29
Figure 4-2. Single Point Power Supply .......................................................................................................... 32
Figure 4-3. Dual Point Power Supply ............................................................................................................ 32
Figure 4-4. Remote Interface Mounting Plate ................................................................................................35
Figure 4-5. Pool Water Piping Schematic ..................................................................................................... 41
Figure 4-6. Negative Pressure Condensate Drain Piping Cross Section ............................................................43
Figure 4-7. Positive Pressure Condensate Drain Piping Cross Section ................................................................43
Figure 4-8. Remote ACC Installation Clearances ...........................................................................................44
Figure 4-9. Remote ACC Installation Around Walls or Obstructions .................................................................44
Figure 4-10. Remote ACC Installation Clearances ..........................................................................................45
Figure 4-11. Remote ACC Installation When Installing Units in Pits ...................................................................45
Figure 4-12. Remote ACC Installation When Installing Units Near Decorative Fences ......................................... 45
Figure 4-13. Remote ACC Above Unit ..........................................................................................................47
Figure 5-1. RIU Keypad ..............................................................................................................................50
Figure 5-2. CPCS Controller (CM1) Display ..................................................................................................51
Figure 5-3. Startup Screen .......................................................................................................................... 53
Figure 5-4. Fault Condition Status Screen - Coil Freeze Warning ..................................................................... 54
Figure 5-5. Main Menu Screen ...................................................................................................................55
Figure 5-6. Status Screen 1: Return Air/Pool Status ........................................................................................55
Figure 5-7. Detailed Status Screen 4: Airflow Status .......................................................................................56
Figure 5-8. Detailed Status Screen 5: Status Overview ................................................................................... 57
Figure 5-9. Detailed Status Screen 6: Operation Mode Stages ........................................................................57
Figure 5-10. Detailed Status Screen 7: Fan Motor Status ................................................................................58
Figure 5-11. Detailed Status Screen 9: Compressor Module Status ...................................................................58
Figure 5-12. Set Points Air Temperature Screen .............................................................................................58
Figure 5-13. Occupancy Schedule Screen ....................................................................................................59
Figure 5-14. Service - I/O Config screen ......................................................................................................59
Figure 5-15. Digital Inputs - Smoke Purge screen............................................................................................59
Figure 5-16. Digital Outputs - Supply Fan screen ...........................................................................................60
Figure 5-17. Analog Inputs - Supply Air screen .............................................................................................. 61
Figure 5-18. Analog Outputs - Recirculation Damper Screen ...........................................................................63
Figure 5-19. Fault Screen 1 – System Status Overview ....................................................................................63
Figure 5-20. Fault Screen 2 – Airflow Status .................................................................................................64
Figure 5-21. Fault Screen 3 – Fan Currents ...................................................................................................64
Figure 5-22. Fault Screen 4 – Compressor Module 1 Fault Screen ................................................................... 64
Figure 5-23. Unit Configuration - Installed Features Menu ...............................................................................65
Figure 5-24. Manual Mode Screen 1 - Overview ..........................................................................................71
Figure 5-25. Manual Mode Screen 4 - Airflow Control: Fan Speed (RPM) ........................................................72
Figure 5-26. Utilities Menu - Set Time and Date ............................................................................................. 73
Figure 6-1. PoolPak Control Panel ................................................................................................................84
Figure 6-2. Multiple Unit Connection Schematic ............................................................................................85
Figure 6-3. Field Wiring - Communications ...................................................................................................85
Figure 6-4. MPK Field Wiring .....................................................................................................................86