Suzuki LT-Z50 - Final Reduction Gear Box Oil; Throttle Cable Play

2-10 PERIODIC MAINTENANCE
FINAL REDUCTION GEAR BOX OIL
FINAL REDUCTION GEAR BOX OIL LEVER CHECK
• Place the vehicle on level ground.
• Remove the right frame cover. (5-4)
• Remove the generator cover 1.
• Remove the oil filler cap 2.
• Inspect the oil level. If the oil level is below the edge of the oil
filler hole, add oil until it flows from the filler hole.
FINAL REDUCTION GEAR BOX OIL REPLACEMENT
• Place the vehicle on level ground.
• Remove the right frame cover. (5-4)
• Remove the generator cover 1.
• Remove the oil filler cap 2.
• Remove the drain plug 3 and drain the oil into an oil pan.
• Reinstall the drain plug 3.
• Pour new oil through the oil filler hole until the oil flows from oil
filler hole.
• Reinstall the oil filler cap 2.
 Final reduction gear box oil capacity:
Oil change: 25 ml (0.8/0.9 US/Imp oz)
Overhaul: 30 ml (1.0/1.1 US/Imp oz)
THROTTLE CABLE PLAY
Adjust the throttle cable play A as follows.
Inspect every 6 months.
Replace every 2 years.
Inspect initially at 1 month and every 3 months there-
after.
PartShark.com
877-999-5686