Toro Reelmaster 5100-D - Front Reels will Not Turn in Either Direction

________________________________________________________________________________________
______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ _
______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ _
______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ _
______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ ___ ______ _
__
__ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __
__ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __
__ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __
__ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __ __
Front Reels Will Not Turn in Either Direction
Cause
S1 not shifting.
Correction
Do electrical diagnostics to make sure that voltage
i
s being applied to S1 and that there is no electrical
fault. See Chapter 5 - Electrical System.
Do cartridge valve service procedure for valve S1.
Interchange S1 with S2 and check operation. Re-
place S1 with a new valve if faulty.
R1 bypassing. Check pressure at port G1 of valve block and adjust
v
alve if necessary.
Do cartridge valve service procedure for valve R1.
Replace R1 with a new valve.
S7 partially shifted. Try operating lift circuit up and down a number of
times.
Do cartridge valve service procedure for valve S7.
S7 energized (should only be energized during lift Check for electrical or controller problem. See Chap-
function). ter 5 - Electrical
System.
VS1 not shifting. Do electrical
diagnostics to make sure that voltage
is being applied to VS1 and that there is no electri-
cal fault. See Chapter 5 - Electrical System.
D
o cartridge service procedure for VS1.
Interchange VS1 with VS2 and check operati
place VS1 if faulty.
on. Re-
Troubleshooting Page 4 -
18 Reelmaster
®
5100-D