Toro Reelmaster 5100-D - Specifications

__________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
________________________________________________________________________________________________________________________________________________________
Specifications
Item Description
Transmission Sauer-Sundstrand M25, U-type
System relief pressure
2WD units 2750 ± 150 psi at 3250 RPM
4WD units 3200 ± 150 psi at 3250 RPM
Charge relief pressure 150 ± 3
0 psi at 3250 RPM
Cooler By-pass pressure 70 ± 10 psi
Filter By-pass pressure 70 ± 10 psi
Oil filter Screw-on type
Auxiliary Pump 3 section, external gear type
S
teering relief pressure 1250 psi (cracking)
Reel Motor (5) External gear type
Valve Block Toro, cartridge logic, elec./hyd. solenoid actuated
Front reel circuit relief pressure 3000 psi
Rear reel circuit relief pressure 2000 psi
Hydraulic Oil – Reel Drive & Steering (Fig. 2)
Group 1 (for ambient temp. consistently below 100° F) ISO type 46/68 anti-wear hydraulic fluid (Mobil 424 or equiv.)
Group 2 (for ambient temp. consistently above 70° F) ISO type 68 anti-wear hydraulic fluid (Mobil DTE 26 or equiv.)
Hydraulic Reservoir – Reel Drive & Steering (Fig. 2) 8 U.S. gal. approx. capacity (9.5 U.S. gal. approx. system capacity)
Oil filter – Reel Drive & Steering Screw-on cartridge type, 50 psi bypass
Transmission Oil (Fig. 1) ISO type 46/68 anti-wear hydraulic fluid (Mobil 424 or equiv.)
Transmission Resevoir 5 U.S. qt. approx. system capacity
1
Figure 1
1. Transmission dipstick cap
Specifications Page 4 - 2
Rev. A
Reelmaster
®
5100-D