Toshiba E-STUDIO2508A - 8.3.6 Other jam

e-STUDIO2008A/2508A/3008A/3508A/4508A/5008A © 2015 TOSHIBA TEC CORPORATION All rights reserved
ERROR CODE AND TROUBLESHOOTING
8 - 100
8.3.6 Other jam
[E030] Paper remaining inside the equipment at power-ON
Relation between the jamming area and the corresponding sensors and covers
(If a jam is occurring in the ADU, LCF, PFP, JSP or OCT check the board in each unit.)
Classification Error content
Other jam Power-ON jam
Proce
dure
Check item Result Measure
Next
Step
1
Open the cover of the unit/
area whose picture is
blinking on the control
panel. Is there any paper
on the transport path?
(Refer to the following
table.)
Yes Remove the paper.
No
2
2
Is the sensor in the
jamming area working?
(Perform the input check
in the test mode: refer to
the following table.)
Yes
3
No • Check if the connector of the sensor is
disconnected.
• Check if any of the connectors on the LGC
board is disconnected.
• Check if the connector pins are
disconnected and the harnesses are open
circuited.
• Check if the conductor pattern on the LGC
board is short circuited or open circuited.
• Replace the sensor
• Replace the LGC board.
3
LGC board • Replace the LGC board.
Parts to be replaced Remark
Sensor Refer to the following table
LGC board
Jamming area Cover Sensor Test mode / Input check
Registration area Automatic duplexing
unit
Registration sensor 03-[FAX]ON/[9]/[A]
1st transport sensor 03-[FAX]OFF/[6]/[A]
Exit area Automatic duplexing
unit
Exit sensor 03-[FAX]ON/[9]/[B]
ADU ADU ADU entrance sensor 03-[FAX]OFF/[1]/[D]
ADU exit sensor 03-[FAX]OFF/[1]/E]
Feeding area
(Main unit)
Feed cover 2nd transport sensor 03-[FAX]OFF/[7]/[A]
LCF LCF side cover LCF feed sensor 03-[FAX]OFF/[4]/[C]
PFP PFP side cover PFP upper drawer feed sensor 03-[FAX]OFF/[2]/[B]
PFP lower drawer feed sensor 03-[FAX]OFF/[3]/[B]
Bridge unit Bridge unit Bridge unit transport sensor-1 03-[FAX]ON/[4]/[G]
03-[FAX]ON/[3]/[G]
Bridge unit transport sensor-2 03-[FAX]ON/[4]/[F]
03-[FAX]ON/[3]/[G]
JSP JSP cover JSP feed sensor 03-[FAX]ON/[3]/G]
OCT OCT cover OCT feed sensor 03-[FAX]ON/[3]/[G]