DV16401.03 Issue 04 May 2021 BD406/PBD406 33
2 Installation
This manual must be available during performance of all tasks.
The installation of the device(s) depends on the device, the aircraft and its equipment and therefore
only general information can be given in this section.
Any deviations from the instructions in this document are under own responsibility.
In this chapter you can read about:
2.1 Packaging, Transport, Storage ................................................................................................... 34
2.2 Device Assignment ..................................................................................................................... 35
Scope of Delivery .............................................................................................................. 35
State of Delivery ................................................................................................................ 35
Additional Equipment ........................................................................................................ 35
Type Plate ......................................................................................................................... 36
Software/Firmware Status – Functionality ........................................................................ 36
2.3 Installation Requirements ............................................................................................................ 37
Rear Panel Installation - BD406 with Control Head .......................................................... 38
Avionic Bay Installation - BD406 without Control Head .................................................... 38
Installation - PBD406 ........................................................................................................ 39
Installation in a Vehicle .............................................................................................. 39
2.4 Dimensions ................................................................................................................................. 40
BD406 with Control Head ................................................................................................. 40
BD406 without Control Head ............................................................................................ 41
BD406 without Control Head with Mounting Kit MK4401 ................................................. 42
PBD406 ............................................................................................................................. 43
Bracket for Vehicle Installation ......................................................................................... 44
2.5 Electrical Interface ....................................................................................................................... 45
Connector Pin Assignments - BD406 ............................................................................... 45
406 MHz Antenna Connector (ANT) ......................................................................... 45
GPS Antenna Connector (GPS) ................................................................................ 45
Grounding Bolt ........................................................................................................... 45
Device Connector P1 - Digital and Analog I/Os ........................................................ 46
Device Connector J1 - Serial Interfaces .................................................................... 48
Connector Pin Assignments - PBD406 ............................................................................. 51
406 MHz Antenna Connector (ANT) ......................................................................... 51
GPS Antenna Connector (GPS) ................................................................................ 51
External DC Voltage (DC IN) ..................................................................................... 51
Headphone / Speaker Output (HDPH) ...................................................................... 52
Device Connector J6 ................................................................................................. 52
Inputs / Outputs ................................................................................................................. 52
Speaker Connection .................................................................................................. 52
Headphone Connection ............................................................................................. 53
Panel Illumination ...................................................................................................... 53
/PWR_EVAL .............................................................................................................. 53
/MSG .......................................................................................................................... 53
/GPO_0 ...................................................................................................................... 53
/GPO_1 ...................................................................................................................... 54
/GPI_0........................................................................................................................ 54
/GPI_1, /GPI_2 .......................................................................................................... 54
/ON ........................................................................................................................ 54
/SDI_9, SDI_10 ...................................................................................................... 54
/GPI_CH ................................................................................................................ 54
IF0 - ARINC Output ............................................................................................... 55
IF1 - Service Protocol Interface ............................................................................. 55
IF2 - GPS Interface (external/internal) .................................................................. 55
IF3 – Transmitter of Targets Status Protocol ........................................................ 56
IF3 - Receiver ........................................................................................................ 56
IF4 - General Purpose Interface ............................................................................ 56
2.6 Aircraft Wiring .............................................................................................................................. 57
Electrical Bonding and Grounding .................................................................................... 57
Wiring - BD406 with Control Head, P1 Connector and Antennas .................................... 58
Wiring - BD406 with Control Head, J1 Connector (PBD406 J6 Connector) ..................... 59
Wiring - BD406 without Control Head, P1 Connector and Antennas ............................... 60
To Next Page
Loading...