Milwaukee, Wisconsin
www.cleaver-brooks.com
Chapter 4
CFC Commissioning
Operating Conditions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
Filling Boiler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
Control Setpoints . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
Model CFC Boiler / Burner Controller . . . . . . . . . . . . . . . . . . . . . . . . . 4-2
CB Falcon Display/Operator Interface . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
Home Page . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
Status Page . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-3
Operation Page . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-4
Lockouts and Alerts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
Controller Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-5
Changing Parameter Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-11
Burner Sequence . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-12
Fan Speed Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13
Initial start-up procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13
Gas Train and Piping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-13
Power-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-14
Operation Check: Gas Valve, Gas Press. Switches, and CAPS . . . . . . 4-14
LOW WATER CUTOFF Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
Low and High Fire Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . . 4-16
Modulation OFF point . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17
Setting Combustion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-17
High Air Pressure Switch settings . . . . . . . . . . . . . . . . . . . . . . . . . 4-19
Limit Controls Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-19
Post start-up checkout procedure . . . . . . . . . . . . . . . . . . . . . . . . . . 4-20
The boiler and its gas connection must be
leak tested before placing the boiler in
operation.
!
Warning